Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Note:-
Question 1-30 are based on basic Engineering Knowledge
Question 31-60 are based on basic Naval Architecture Knowledge
Questiong 61-100 are Psychometric and Aptitude Test
01. A thin cylinder of inner radius 400mm and thickness 20mm is subjected to an internal
pressure of 5MPa. The average circumferential (hoop) stress in MPa is
(A) 100
(B) 250
(C) 500
(D) 1000
ANSWER
ANSWER
ANSWER
ANSWER
6. Which of the following is the correct data structure for solid models?
(A) solid part → faces → edges → vertices
(B) solid part → edges → faces → vertices
(C) vertices → edges → faces → solid parts
(D) vertices → faces → edges → solid parts
ANSWER
7. A linearly elastic and perfectly plastic material is loaded slightly above the
proportionality limit. This will lead to
(A) Fracture
(B) Small deformation
(C) Large deformation
(D) Cracking
ANSWER
ANSWER
ANSWER
ANSWER
ANSWER
ANSWER
13. For flow of viscous fluid over a flat plate, if the fluid temperature is the
same as the plate temperature, the thermal boundary layer is
(A) thinner than the velocity boundary layer
(B) thicker than the velocity boundary layer
(C) of the same thickness as the velocity boundary layer
(D) not formed at all
ANSWER
ANSWER
15. FRP is a
(A) Thermoplastic
(B) Thermoset
(C) Composite
(D) Elastomer
ANSWER
ANSWER
ANSWER
ANSWER
20. This type of pipe is commonly used for water, steam, oil, and gas:
(A) Wrougt Iron or Copper
(B) PVC or steel
(C) Steel or Wrought Iron
(D) Copper or PVC
ANSWER
21. When dimensioning piping drawings, you give the lengths of all runs of this type:
(A) Straight
(B) Angular
(C) Filleted
(D) Transverse
ANSWER
22. The ________ tool on the Dimension tool bar places the length of an arch on a drawing.
(A) Arc Radius
(B) Arc Length
(C) Radius
(D) Diameter
ANSWER
23. This is a thin solid line directing attention to a note or dimension and starting
with an arrowhead or dot:
(A) Dimension line
(B) Extension line
(C) Leader
(D) Specification
ANSWER
ANSWER
25. In an assembly section, these parts should have their section lines left out or
shown solid black:
(A) Bolts
(B) All fasteners
(C) Thin parts
(D) Rivets
ANSWER
ANSWER
28. A full scale technical drawing will have a scale factor of ________.
(A) 1 : 1
(B) 1 : 2
(C) 2 : 1
(D) 1 : 4
ANSWER
ANSWER
ANSWER