Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
CRYSTALLINE
CIGS
PARAMETERS SILICONE SOLAR (NANO TECHNOLOGY)
MODULES MADE IN USA
Working 400nm to 700nm 300nm to 1300 nm.
Spectrum Total Band Width = 300nm Total Band Width = 1000nm
Remark:
Crystalline Silicone Solar Modules Can Absorb Only Visible Range Of
Light Spectrum, Whereas CIGS Nano Technology Solar Modules Can Absorb
UV-VISIBLE -INFRARED Ranges Of Light Spectrum, So That Daily Power
Production Will Be Far Better Than The Old Technology .
Approximately 30-40% More Energy Can Be Produced.
Temperature HIGH Temperature LOW Temperature
Coefficient Coefficient Coefficient
Remark:
Crystalline Solar Modules cell efficiency will drop drastically at high
atmospheric temperature (>35C). 0.5% Efficiency will drop for each one
degree increase. The module exposed at 35C for 1 Hour may increase the cell
temp to 70-80C. So the efficiency drop will be drastically high. This
phenomenon is minimized in CIGS modules as the temperature coefficient is
very low.
Light Induced HIGH Light Induced LOW Light Induced
Degradation (LID) Degradation Degradation
Remark:
In Crystalline Modules light induced degradation (LID) is very high because of
light soaking effect. In CIGS modules LID is very minimal because it is already
soaked in light.
Unit Generation 3100 - 3700 Units Per 5000 - 5600 Units Per
Per MW Day Day
Remark:
The performance of Crystalline Solar Module Power Plants in India is very poor
as the climatic conditions are variable and not suitable for Crystalline Silicone.
As per the study conducted by Indian Institute of Science and reported to
Central Electricity Regulatory commission, New Delhi; Crystalline power
plants are generating an average of 3100-3700 units per day per one MW
whereas CIGS power plants are generating 5000 - 5600 units per day per one
MW.
OTHER ADVANTAGES OF CIGS PANELS
HIGH-IMPACT RESISTANCE TO WIND AND SNOW
The CdF CIGS PV Module applies an ultra-thin Sodium Calcium glass substrate and as a
result, has tremendous flexibility and stability. We have incorporated additional structural
reinforcement into this module, allowing for enhanced mechanical load.
Our products have a wind resistance and endurance capacity of up to 2400Pa and snow
resistance and endurance capacity of up to 5400Pa.
This not only increases the reliability and durability of our products, but also allows them to
be transported and installed in distant locations without the worry of impact and damage.
EASE OF INSTALLATION
In contrast to the Crystalline Silicon solar module, the CdF CIGS PV Module is minimally
impacted by the direction of sun exposure, making it particularly suitable for areas where
there are construction and terrain limitations.
We have optimized the size and weight of the CdF CIGS PV Module, so that the
installation process is simple and safe.