Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1 RRU3908
The RRU3908 is an outdoor RF remote radio unit, which performs modulation, demodulation,
data processing, and combining and dividing for baseband signals and RF signals.
Label Description
RST Reset button
VSWR -
RTN+ Terminals for power cables
NEG-
NEG(-)1
The GSM power is measured when the modulation scheme is GMSK. If the modulation scheme is
8PSK, the output power is 1.8 dB less than that in GMSK mode.
The RRU3908 at 1800 MHz of the current version only supports the GSM mode in terms of
software. The RRU3908 at 1800 MHz supports the UMTS and LTE modes in terms of hardware.
When RRU3908 is located in the area at an altitude of 3500 m to 4500 m, the output power back-off
is 1 dB. When RRU3908 is located in the area at an altitude of 4500 m to 6000 m, the output power
back-off is 2 dB.
1 0 40 0
2 0 40 0
3 0 20 0
4 0 15 0
5 0 12 0
6 0 10 0
1 1 40 30
1 1 30 40
1 2 30 20
2 1 20 30
2 1 15 40
2 2 15 20
3 1 10 30
3 2 10 10
4 1 7.5 20
4 2 7.5 10
5 1 6 20
0 1 0 40
0 2 0 30
0 3 0 20
0 4 0 15
1 0 20 0
2 0 20 0
3 0 15 0
4 0 15 0
5 0 10 0
6 0 10 0
1 1 20 40
2 1 15 30
3 1 10 30
2 2 10 20
1 2 20 20
3 2 10 15
0 1 0 40
0 2 0 30
0 3 0 20
0 4 0 15
1 0 40 0
2 0 40 0
3 0 20 0
4 0 20 0
5 0 13 0
6 0 13 0
7 0 10 0
8 0 10 0
1 1 40 40
2 1 20 40
2 1 30 20
3 1 13 40
4 1 10 40
1 2 40 20
2 2 20 20
3 2 13 20
4 2 10 20
0 1 0 40
0 1 0 2 x 40 (MIMO)
0 2 0 40
0 2 0 2 x 20 (MIMO)
0 3 0 20
0 3 0 2 x 10 (MIMO)
0 4 0 20
0 4 0 2 x 10 (MIMO)
Table 1-8 lists the typical configurations of the RRU3908 V2 at 900MHz in compliance with
ETSI TS 100 910 V8.20.0.
2 1 20 40
2 1 30 20
3 1 13 40
4 1 10 30
1 2 20 20
2 2 20 20
3 2 13 20
4 2 10 20
0 1 0 60
0 1 0 2 x 40 (MIMO)
0 2 0 40
0 2 0 2 x 20 (MIMO)
0 3 0 20
0 3 0 2 x 10 (MIMO)
0 4 0 20
0 4 0 2 x 10 (MIMO)
Item Specification
~
880 905 ~
925 950
UTRP3 8 E1s/T1s
UTRP4 8 E1s/T1s
NOTE
The typical power consumption for GSM is reached when the base station works with 30% load
and power control and DTX are enabled. The maximum power consumption for GSM is reached
when the base station works with 100% load.
The typical power consumption for UMTS is reached when the base station works with 50% load.
The maximum power consumption for UMTS is reached when the base station works with 100%
load.
The GSM output power per carrier is sharing power in compliance with the specifications for
multi-carrier base station (Class2).
The GSM output power per carrier is non-sharing power in compliance with ETSI.
Anti-seismic IEC 60068-2-57 (1999-11) Environmental testing -Part 2-57: Tests -Test Ff:
performance Vibration-Time-history method
EMC The DBS3900 meets the Electro Magnetic Compatibility (EMC) requirements and
complies with the following standards:
R&TTE Directive 1999/5/EC
R&TTE Directive 89/336/EEC
ETSI EN 301489-1/8/23
3GPP TS 25.113
ETSI EN 301908-1
ITU-T SM 329-10
FCC PART15