Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Automatical Solution for EPS function Step1: Install auxiliary contact to contactor.
Introduction
The X-hybrid E inverter supports both on-grid and off-grid modes. When the grid is on, the inverter will
have output through the AC output, and it will have output through the EPS output when the grid is off.
User can realize this function automatically with an external contactor installed. Note1: Please lock tightly.
Following is an assitant guide for installation, please note all operations must apply to local country note 1
relevant regulations.
Components
contactor auxiliary contact module accessoies
EATON_DILM40C EATON_DILM150C-XHI11 EATON_DILM65-XMV Step2: Install machanical locks.
XTCEXMLD a ball
note 2
×2
×1
×2 ×2
Note2: Put the ball into
×2 the slot of two contact
surfaces.
Cables note 3
0mm
contactors together with
12 AWG Coil cable orange/blue cable accessoies.
AC EPS BAT
+ _
PE L N L N PE
Breaker A1 NC 1L1 5 L3 A1 NC 1L1 5 L3 GRID-L GRID-N
L 2T1 6 T3 2T1 6 T3
A2 NC A2 NC
N
KM1 KM2 A1 NC 1L1 5 L3 A1 NC 1L1 5 L3
PE A2 NC 2T1 6 T3 A2 NC 2T1 6 T3
KM1 KM2
KM1 KM2
A1 NC 1L1 5 L3 A1 NC 1L1 5 L3
A1 NC 1L1 5 L3 A1 NC 1L1 5 L3
A2 NC 2T1 6 T3 A2 NC 2T1 6 T3
A2 NC 2T1 6 T3 A2 NC 2T1 6 T3
KM1 KM2
KM1 KM2
Load-L Load-N
Load-L Load-N
Step5: Connect two sets of coils and two auxiliary contacts in series respectively with cable(12 AWG).
GRID-L GRID-N
A1 NC 1L1 5 L3 A1 NC 1L1 5 L3
A2 NC 2T1 6 T3 A2 NC 2T1 6 T3
KM1 KM2
Grid-PE
Grid-N
Grid-L
NC
EPS-L EPS-N
A1 NC 1L1 5 L3 A1 NC 1L1 5 L3
A2 NC 2T1 6 T3 A2 NC 2T1 6 T3
KM1 KM2