Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Government of India
Power & Telecommunication Co-ordination Committee
(To be answered by the Authorities In-Charge of Power System while Applying for PTCC Route Approvals.)
1.0 Please supply data of the power system as per details below:
Note: By relevant is meant all the power stations, which under normal operating conditions will feed into a
fault occurring within or outside the parallelism section as well as all lines on which such fault current
would flow.
Please state if the neutral points of the power system are (i)
insulated, or (ii) earthed. If the latter, please indicate the type
1.3 of earthing, e.g. solidly earthed, earthed through Peterson coils,
eathed through resistance or reactance. Give also full
particulars.
2.0 Please supply the following data in respect of the particular power line for which approval is sought.
2.6 Will the power line initially be charged at some lower voltage?
Page 1 of 10
2.7 Probable date of commencing the construction.
Please indicate the protective device adopted for the line. In respect
of lines protected by circuit breakers, please furnish also the type of
5.0 the lines and relaying proposed and the total time (Breaker and
Relay) for clearance of ground faults on the line with normal relay
settings.
Please indicate the soil resistivity in the area covered by the line. The
soil resistivity should be measured by the four electrode method
Details submitted with Annexure-IV,
6.0 using an inter electrode spacing of 50 meters (150 feet). The
enclosed herewith
measurements may be made at every 2 or 3 kms .along the length of
the line.
Page 2 of 10
Please indicate the number of crossing between the proposed
alignment and the telecommunication lines involved and state if the
7.0 crossing arrangements will be provided in accordance with the code
of Practice for Crossings issued by the Power and
Telecommunication Co-ordination Committee.
Whether any Railway lines are existing within 8 kms. on either side Details submitted with Proforma-II,
9.1
of the power line: enclosed herewith
While applying for route approval of the Committee, the above particulars should be furnished to :
Director (PTCC), Central Electricity Authority, Load Dispatch & Telecommunication Division, PTCC
i
Directorate, NREB Building, Shaheed Jeet Singh Marg, Katwaria Sarai, New Delhi 110016.
Place: Signature:
Date: Name:
Designation:
Contact No.
Page 3 of 10
Annexure - I
Relevant Network Sketch for "Name of Proposed Power Line"
Signature :
Name :
Designation :
Page 4 of 10
Annexure - II
Equipment Details for "Name of Proposed Power Line"
2 Transformers
Sr.No. Name of the Power Station or Connections Voltage Rating Transient Reactance
Sub-station HV/LV Ratio in MVA (Percentage Reactance at
its own Base)
1
2
3
3 Reactors
4 Earthing Transformers
Sr.No. Name of the Power Station or Current Rating Voltage Time Transient Reactance
Sub-station (Short Time) Rating (Percentage Reactance at
its own Base)
1
2
3
Signature :
Name :
Designation :
Page 5 of 10
Annexure - III
Tower Key Diagram for "Name of Proposed Power Line"
Signature :
Name :
Designation :
Page 6 of 10
Annexure - IV
Soil Resistivity Statement for " Name of Proposed Power Line "
Length in kms :
Method Adopted : Four Electrode Method
Formula : ρ=2ΠaR
Where, ρ = Soil Resistivity in Ohm-Meter.
R = Megger Reading in Ohms.
a = Distance Between Two Electrodes in meters.
Note: Inter Electrode Spacing Should be Kept 50 Meters
Megger Soil
Sr. Reading Resistivity
No. Distance from either end Location Name/No. (R) (ρ) Soil Type
Signature :
Name :
Designation :
Page 7 of 10
Annexure - V
Telephone Exchanges Details for " Name of Proposed Power Line "
Signature :
Name :
Designation:
Page 8 of 10
Proforma-II
Railway Line Details for "Name of Proposed Power Line"
Signature :
Name :
Designation :
Page 9 of 10
EHV Line GPS Co-ordinates for "Name of Proposed Power Line"
From To Voltage Level Route Length Number of Type of Size of Type of Earth Number of Size of Earth
(Sub-station) (Sub-station) (kV) (kms) Ckts. Conductor Conductor Wire Earth Wire Wire
Signature :
Name :
Designation :
Page 10 of 10