Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
For DC blocklng. Since capacilor reactance becomes largar at lower frequencies, the output nolse can be adversely affected by signal source
resistance·dependent 1/f noise. In this case, a lower reactance value should be chosen. In arder to remove pop noise at power-on, larger
C3,C4
values of capacitance should be chosen lar C3 and C4, which determine the Input time constant, and smaller values far es and C6 in the NF
NF capacltors.
circuit.
These determine the low·side cut-of frequency.
1
f = [Hi]
CS, C6 L 2rrxC5xR5
Decoupling
A large valuecapacitors.
should be chosen for es to maintain voltage gain at low lrequencies. However, because this would tend to increase the shock
C1S
This
nolseremoves shocka noise
at power-on, value and ripple
largar !hanvoltage fromnecessary
absolutely lhe supply.should be avoided.
Bootstrap capacitors.
C11,C12
II these capacilors are made small, then the total harmonic distortion et low frequencies increases significantly.
Oscillation prevention capacitors.
C9,C10 These should be insertad as clase as possible to the IC supply pins to reduce supply impedance and hence provide stable IC operation.
Electrolytic capacitors are recommended.
Ripple filler capacitar.
C14
This forms a ripple filler in combination with interna! íranslsíor TR10.
Oscillation prevention capacitor.
C7
Mylar capacitors are recommended far their excellent 1hermal and frequency characteristics.
R3,R4 lnpu1 filter resistors.
Input bias resistors.
R1, R2
These are used to bias the input pins at zero potential. The input impedance is 1argely determinad by this resistance.
Voltage-gain VG setting resistors.
R5,R9
(R6,R10)
VG = 40dB Is recommended using AS, AS= 560.Q, and R9, A10 = 56kil. Gain adjustmen1s are bes1 made using R5 ar AS. Ir gain
adjustments are made using A5 ar R6, then set A1, R2 = A9, R10 to maintaln VN balance stabllity.
A11, A13 Bootstrap resistors.
(A12, A14)
These reslstors determine the quiescent curren!. Values of 2.2kn and 2.2kn are recommended.
Ripple fllter resistor.
A21
This resistor performs as predrlver transistor limlting resistor during load short clrcults.
A18 Clipping plus/minus balance resistor.
Ripple filler resistors.
A19, R20 When mutingtransistorTA11 is on, current flows from ground through TR11 to -Vcc· Valuesof 1kn (0.5W) and 1kn (O.SW) are
recommended.
A15, R16 Oscillation prevention resistors.
Condensadores NF
Estos condensadores fijan el límite de las frecuencias bajas.
C5,
100 uF Para lograr una buena respuesta de frecuencias bajas, es mejor
C6
incrementar C5 y C6. sin embargo no los incremente más de lo
necesario, porque el nivel de ruido seco, al encendido será más
alto.
R3,
R4 1K Resistencias para filtro de entrada.
R11,
entre Resistencias de refuerzo (Boostrap)
R13,
R12, 2.2K y La corriente inactiva es resuelta por estas resistencias 3.3 K Ω
R14 3.3 K + 3.3 K Ω se recomienda usar este valor de resistencias.