Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
W4800
GEN 2000® Electronics
Technical Data
Power Requirements
- AC Non-heated 90 ... 250 VAC, 50 ... 60Hz, 15 VA
- AC Heated 115 or 230 VAC, 50 ... 60 Hz, 25 VA
- DC Non-heated 20 ... 60 VDC (< 100 mV, 1 ... 1000Hz ripple),
15 VA
- DC Heated 24 VDC +/- 10%, 25 VA
- Wire Size 1.63 ... 0.64 mm (14 ... 22 AWG) per local
electrical code
Electronic Versions
Approvals Dimensions
The W4800 is not normally supplied with hazardous area certifications. If
certification is required, refer to specifications for the LSG detector.
5.50 12.50
11.00 [279 mm]
[140 mm] [317 mm]
Adjustment
6.00 [152 mm]
The detector is adjusted using a PC with Ohmview configuration and
1.50 [38 mm]
calibration software via HART modem. Alternatively, a Rosemount 275
3.00 [76 mm] 0.75 [19 mm]
or 375 HART handheld communicator with pre-installed Ohmart device
description may be used.
Electrical Connection
Terminals 2.31
[59 mm]
1 Power in (L)
9.13 [233 mm]
2 Power in (N)
3 Relay NO Dimensions
4 Relay C
5 Relay NC
1 16 mm (8 x 0.63") Holes as Shown
6 + Frequency
2 Frame Width + 229 mm (9.0")
7 - Frequency
3 SHGL Source Holder 114 mm (4.5"), SHLD Source Holder 176 mm (6.94")
8 + 6V
4 Frame Height (Depends on Belt Width, Consult Factory)
9 COM
5 Frame Width (Max. Belt Width)
10 - 6V
6 Frame Width + 305 mm (12")
11 + Auxiliary
7 3/4" NPT (2 Places)
12 - Auxiliary
13 + mA
14 - mA
Information
You can find additional information about VEGA product offerings from our
home page, www.vega-americas.com. Brochures, operating instructions,
quick reference guides, specification sheets, and drawings are also avail-
able from the Downloads section of our homepage.
Device Selection
Contact