Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Section 5: Sheet 3
UL Listed as ITC/PLTC — Instrument Tray Ca- • In addition, the aluminum CLX sheath ex-
ble/Power Limited Tray Cable for use in ceeds the equipment grounding
accordance with Article 727 and Article 725 of requirements of NEC Section 250.118 and
the National Electrical Code. 250.122, and can be used as the equipment
These cables comply with UL 2250 and UL 13 grounding conductor.
for PLTC, CL2 and CL3. • Excellent compression and impact resis-
tance.
Applications
Okonite Type C-L-X P-OS (Pair/Triad - Overall
• Lower installed system cost than conduit
or EMT systems.
Shield) instrumentation cables are designed for
use as instrumentation, process control, and • OSHA Acceptable.
computer cables in ITC non-classified or labeled • Meets API Standards 14F and 14FZ.
circuits up to 150 volts and 5 amps (750VA) and • Suitable for low temperature installation of
in Class 2 or 3 Power-Limited circuits where -40°C.
shielding against external interference is re-
quired, but shielding against interference among
A Bare Stranded Copper Conductor groups is not required; indoors or outdoors; in
B Okoseal Insulation wet or dry locations with conductor operating
C Twisted Pair/Triad temperatures up to 105°C; in cable trays; in
D Tinned Stranded Copper Drain Wire raceways; supported by a messenger wire; un-
E Aluminum/Polyester Tape der raised floors; for direct burial. Suitable Class
F Rip Cord I, Division 2, and Class I, Zone 2 Class II, Divi-
G Inner Black Okoseal Jacket sion 2, or Class III, Division 2 and Class I, Zone
H Impervious, Continuous Corrugated
2 hazardous locations. Also for use as
Aluminum C-L-X Sheath
Power-Limited fire protective signaling cable
J Outer Black Okoseal Jacket
(FPL) per NEC Code 760. The C-L-X sheath
C-L-X Type P-OS Product Data
Type ITC/PLTC Armored Instrumentation Cable Section 5: Sheet 3
Single Pair or Triad - Overall Shield 300V - 105°C Rating
For Cable Tray Use UL
R
Conductors: 16 AWG
Okoseal Insulation: 15 mils
es
t
gh
ch
ht
es
ds
ei
ig
In
rs
ch
r
in l
ils
q na
’) W
’) e
be
ria
ai
.-
es e
In
00 t W
-
)
ch bl
N r J -m
(s o
fP
00 ip
um
et
.D
fT
In nes et
al t
= ti
.-
in ke
In a
10 h
) ck
10 e
O
s
k k
a ec
.- lC
ro
ro
.D
s/ S
s/ x N
N
ic ac
ils a
re -S
om a
x
O
.D a
og
be
J
be
Th r J
(lb ro
O min
(lb ro
A ss
(m er
-X
um
al
um
ne
pp
pp
ne
ut
ro
-L
at
o
In
N
A
A
N
C
N
C
C