Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
uk
September 2, 2017
BMW EDC17CP02:
( note: k tag master price depends on quality and versions. You’ll get what you pay for.)
3.Reconnect the ECU to the vehicle and start the engine, in order to make sure that it is still
working and has not been damaged in the opening;
6.Always make a backup copy of the ECU before Reading and / or Writing.
Instructions: 3 steps to read/write EDC17 CP02 using Ktag ecu programming tool
Step 1:
Connect to the ECU according to the pinout provided for each model
connection mode
2. AC Adaptor 1400SWALIM
4. Adapter 14P600KT04
3. Connect the AC Adaptor 1400SWALIM to the upper illumination deck and the Tricore
module;
4. Set the adapter 14P600KT04 into the compartment of the frame and lower it on the
ECU;
Hardware 1
OR
Hardware 2
1. Ease the wire of the probe 14P800ABD3 into the BOOTD connector of the adapter.
Notice: The adapter switch must be set to OFF as shown in the picture:
1. Connect the ribbon cable 14P600KT03 to the adapter and the Tricore module
2. AC Adaptor 1400SWALIM
4. Adapter 14P600KT04
6. Solder wire
» Pin Boot connected to the adapter (click here for more information)
1. Connect the Tricore module 14P600BTLR to the tool and the AC Adaptor
1400SWALIM;
4. Solder a wire to pin Boot shown in the picture, depending on the ECU hardware, and
ease it into the BOOTD connector of the adapter.
Notice: The adapter switch must be set to OFF as shown in the picture:
Hardware 1
OR
Hardware 2
1. Connect the ribbon cable 14P600KT03 to the adapter and the Tricore module;
2. Remove the soldered wire before re-installing the ECU on the vehicle.
1. Connect the Tricore module 14P600BTLR to the tool and the AC Adaptor
1400SWALIM;
2. Solder a bridge on the two programming pads shown in the picture, depending on the
ECU hardware:
Hardware 1
OR
Hardware 2
2. Set the adapter 14P600KT04 into the compartment of the frame and lower it on the
ECU.
Notice: The adapter switch must be set to ON as shown in the picture:
1.
2.
1. Connect the ribbon cable 14P600KT03 to the adapter and the Tricore module;
♦ Direct connection
Material needed:
2. AC Adaptor 1400SWALIM
3. Cable 14P600KT02
4. Solder wire
1. Solder a wire on pin Boot shown in the picture, depending on the ECU hardware:
Hardware 1
OR
Hardware 2
1. Connect the Tricore module 14P600BTLR to the tool, the AC Adaptor 1400SWALIM
and the cable 14P600KT02;
2. Connect the cable 14P600KT02 to the ECU connector according to the pinout
below:
Color Description
Pin
Pin 5,7 Red +12V
1.
Remove the soldered wire before re-installing the ECU on the vehicle.
Step 2:
Step 3:
->Backup
To make a full backup containing all data of the memories on the ECU:
1. Select Tool:
1. Select Backup Read:
To rewrite the backup file, and so restore the ECU to its original conditions, select Backup Write
from Tool menu.
Select Reading to read the file containing the maps for engine control.
Select Writing to write the modified file.
1. V2.13 KTAG K-TAG FW V7.003 KTM100 ECU Programming Master Version from
cardiagtool.co.uk
Mobile Desktop