Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
OUTPUTS THROUGHS
F1 (30A) F1 (20A)
FUSED
°Power Feed EAPU (Air Processing Unit), BAT - X57/13
PASS-
F2 (20A)
87a
87a
X4/1 - Power Feed Spare Output 1, BAT
30
30
Cabin HVAC Controller, ACC - X1/10
X4/2 - *Power Feed Spare Output 3, BAT X57/15 - Fuel Water Separator Heater Element, IGN
87
Sleeper HVAC Controller, ACC - X1/15 F3 (20A)
IGNITION CONTROLLED OUPUTS
87
Power Feed 1 ABS/BS, BAT - X52/7
85
Note: R1
86
CPC, IGN - X2/4
85
86
F3 (30A) F4 (10A)
*Advertising Light, ACC – X3/4 Power Feed 2 ABS/BS, BAT - X52/4 F5 (20A)
87a
87a
30
X5/1 - Power Feed Spare Output 2, BAT
30
87
CONTROLLED
*Body Builder Connector: IGN - X9/11
87
86
85
F6 (15A)
IGNITION
Tire Pressure Monitoring, IGN - X10/1
85
86
Mirror Adjust switch supply, ACC - X10/2 Emergency BAT, Chas - X51/5 X52/6 - Power Feed ABS/BS, IGN
Service Brake Pressure Switch, Supply (chopped) - X10/7 F7 (10A)
87a
30
Pwr Feed Slpr Thermostat (Opt Idle), IGN - X10/10 F19 (20A) Air Dryer (Pneumatic, Electrically Heated), ACC - X57/4
87a
30
X53/3 - °Rear View Camera, IGN
87
Radio, ACC - X10/18 X1/12 - *Heated Seats, IGN
87
X57/1 - °Power Feed EAPU/WIF Module, IGN
86
Note: R3
85
86
IGN Supply, Not Connected - X58/2
*Rain/Light Sensor, BAT - X11/21
85
F6 (15A)
Rear Baggage Compartment Lights - X12/12 F8 (20A)
87a
87a
30
X6/15 - 12V Power Receptacle 1 (Dash, Cigar), BAT
30 X53/7 - Trailer Turn Lamp Right
87
Ignition Switch - BAT - X13/7 F7 (15A) Hard Wired ISS, Chas - X51/3
87
Park Brake Switch Supply (chopped) - X13/9
86
85
Low Air Pressure Switch Supply (chopped) - X13/11 X6/9 - 12V Power Receptacle 2 (Dash, Phone), BAT
Marker Lamp, Side Right - X52/1
85
86
87a
87a
30
*Auxiliary Circulation Fan-Windshield, ACC - X16/5
X6/3 - CB Radio, BAT Marker Lamp, Corner Rear Left - X53/2 X55/2 - Trailer Marker Lamps
87
87
86
85
85
86
HVAC Pressure Transducer, Supply (+5V) - X19/17 X3/15 - 12V Power Receptacle 3 (Sleeper, Cigar), BAT *End of Frame Primary Trailer Turn Lamps Right - X56/7
Engine ECU, IGN - X19/18 *Diff Lock Feedback Switch Supply (Chopped), FA2 - X56/8
87a
F16 (7.5A) F11 (30A)
87a
30
30
Ether Start Power, IGN - X19/20 *End of Frame Primary Trailer Turn Lamps Left - X56/10
X3/5 - Standalone HVAC, BAT *Diff Lock Feedback Switch Supply (Chopped), FA1 - X56/11 X54/1 - Trailer ABS Connector (7), IGN
87
87
Temp Sensor Outside Air, IGN - X20/13 *Diff Lock Solenoid Driver, FA1 and FA2 - X56/12
86
85
*Distance Sensor (Adaptive Cruise Control), BAT - X20/19 *End of Frame Primary Trailer Tail Lamps - X56/13
85
86
87a
F23 (15A) X6/6 - Fleet Management System, IGN
30
87a
30
*Auxiliary Heater [ESPAR] - X2/1 X6/8 - *Power Feed Gauge Pyrometer, IGN X55/4 - Trailer Stop Lamps
Turn Right Rear, Lower - X58/1
87
87
Hard Wired ISS, CAB - X2/10 X6/10 - Power Feed Gauge Axle Temp, IGN
X6/11 - Power Feed Gauge Engine Oil Temp, IGN Tail Lamp, Right - X58/3
86
85
86
85
Utility Light - X3/7 F24 (10A) Turn Left, Rear, Lower - X58/10
License Plate Lamp (First) - X58/12
X2/9 - Diagnostic Connector, IGN Marker Lamp, Side Right - X58/13 F14 (30A)
Door Open Status ICU Input - X8/5 X6/16 - Instrument Cluster, IGN
87a
Note:
Door Sill Lamp Driver - X8/9
R8
Tail Lamp, Left - X58/18
87
85
*Body Builder Connector: Revolution (W) - X9/1 Stop Lamp, Rear Right Lower - X58/20
*Body Builder Connector: Vehicle Speed (C3) - X9/2 F26 (5A) X2/14 - *Collision Avoidance System, IGN
Function Pin 1 - X9/3 Stop Lamp, Rear Left Lower - X58/21
*Body Builder Connector: Park Brake - X9/4 X3/6 - *SRS Airbags, IGN F13 (20A)
87a
30
87a
87
Transmission Neutral Switch, Supply - X59/2
87
86
85
Function Pin 3 - X9/7 X3/9 - *Amplifier Power, ACC Note: R9
86
85
*Body Builder Connector: Backup Lamp - X9/9 Diff Lock Feedback Switch Supply (Chopped), RA1 - X59/19
*Body Builder Connector: Marker Lights - X9/10 F27 (10A) °Diff Lock Feedback Switch Supply (Chopped), RA2 - X59/20
*Body Builder Connector: Tail Lights - X9/12 X8/8 - Heated Mirror Driver
87a
30
Instrument Cluster, HL Wake Up - X10/17 X14/2 - 12V Power Receptacle 6 (Sleeper, Refrigerator), BAT Power Feed 2 ABS/BS, GND - X52/9 X51/2 - SAM_Chas CAN_H - Cabin
30
*Diff Lock ICU Indicator, RA2 - X11/1 Marker Lamps, Corner Rear Left, GND - X53/4
Washer Level, ICU Indicator - X11/2 °Rear View Camera, GND - X53/6 X53/5 - Trailer ABS Connector (7), ABS Detection
86
85
Electrical Global Fault Indicator - X11/3 Marker Lamps, Side Left, GND - X53/8
*Fuel Water Separator ICU Indicator - X11/4 F31 (20A) X56/4 - Diff Lock Solenoid Return, FA1 and FA2
87a
Diff Lock ICU Indicator, RA1 - X11/5 X14/1 - 12V Power Receptacle 5 (Sleeper, Cigar), BAT X56/5 - Diff Lock Feedback Switch Return, FA1
30
Low Air Pressure Switch ICU Indicator - X11/6 Trailer ABS Connector (7), GND1 - X54/3
X56/6 - Diff Lock Feedback Switch Return, FA2
87
Air Filter Restriction ICU Indicator - X11/8 X58/7 - Fuel Level Sensor, Feedback
X2/15 - Area Lighting (Lwr Bunk & Slpr Wrk Srfc), BAT
85
86
High Beam ICU Indicator - X11/9 °Power Feed EAPU (Air Processing Unit), GND - X57/2
Turn Signal Left ICU Indicator - X11/11 F34 (3A) Air Dryer (Pneumatic, Electrically Heated), GND - X57/3 X59/3 - Backup Switch, Return
87a
Alternator No Charge ICU Indicator - X11/12 X16/7 - Dome Lamp Cab, BAT Fuel Water Separator Heater Element, GND - X57/5
30
Turn Signal Right ICU Indicator - X11/13 X59/9 - Fuel Water Separator Sensor, Feedback
Park Brake Switch ICU Indicator - X11/14 F35 (15A) X59/10 - Temperature Sensor Rear Axle 1, Feedback
87
X16/17 - Overhead Compartment Lights, BAT Marker Lamps, Side Left, GND - X58/4 X59/13 - Temperature Sensor Rear Axle 2, Feedback
Tail Lamp, Right, GND - X58/5
85
86
Footwell Lamp - X12/3 Tail Lamps, Left, GND - X58/8 X59/15 - Diff Lock Feedback Switch Return, RA1
Reading Lamp 1 (Dimmable/Theater) - X12/6 F17 (20A) Marker Lamp, Side Right, GND - X58/14 X59/16 - Diff Lock Solenoid Return, RA1 and RA2
87a
General Sleeper Lamp - X12/9 X3/3 - 12V Power Receptacle 4 (Sleeper, Cigar), BAT X59/18 - Transmission Neutral Switch, Return
30
Turn Left Front Side - X12/15 Fuel Level Sensor, GND - X58/15
F36 (15A) X59/21 - Diff Lock Feedback Switch Return, RA2
87
Reading Lamp 2 (Dimmable/Theater) - X12/16 Temp Sensor Rear Axle 2, GND - X59/14
Dome Lamp, Rear - X12/17 X1/13 - *Auxiliary Circulation Fan, Sleeper, BAT Temp Sensor Rear Axle 1, GND - X59/17
86
85
Turn Right Front Side - X12/18 X16/13 - Reading Lamp 4, BAT SAM CHAS KEY:
Clearance Lamps Front 2 - X16/4 F39 (15A) X(connector)/(cavity) – Pin description
87a
30
Clearance Lamps Front 1 - X16/8 X17/1 - Power window Pass Side, ACC ° indicates Midline or Highline function
87
BAT
BAT
Marker Lamps, Corner Front Left - X18/16 be normally open, the trailer power SAM switches relay 9 on and off, which
X2/12 - MSF, BAT
High Beam, Right - X18/17 NOTE R3: circuit is enabled only if the key is in switches the power to fuse 13 on and
DRL (Daytime Running Lights), Left - X18/18 F5 (10A) This relay has +12v at pin 86 and is IGN position or enabled through a off—thus flashing the trailer tail lamps.
Turn Left Front Corner - X18/19 X2/3 - OBD J1939, BAT 87
Low Beam, Right - X18/20 grounded to the SAM CHAS at pin 85. switch (depending on SAM 87
Horn (Electric), Control - X18/21 X2/6 - OBD DCDI, BAT parameterization) 87a 87a
All other relays except for SAM CHAS 86 85 86 85
F8 (15A) R1 are powered through pin 85 and If prong 87 is missing, the circuit is 30 30
2 1
R11 R5 R6 F9
15
16
18
13
18
30
X5
1 2
3 4
20 F10
Standalone HVAC, GND - X3/13 X6/12 - Power Feed Clock Cab, BAT 15 R1 20 X14
4 3
2 1
F37 (15A)
3
30
1
3
CGW, GND - X3/16 R3
3
X6/14 - Power Feed Clock Sleeper, BAT X2 30
1
18
16
F11
1 2
3 4
5 3
1
15 15 30 30
Power Feed Spare Output 1, GND - X4/3
16
18
3
1
15 R8
*Power Feed Spare Output 3, GND - X4/4 X3 25 10 15 20 F14
15
Power Feed Spare Output 2, GND - X5/3 7.5
15 X16
R5 R14 F12
1 2
20 20
3 4
3
1
R9
1
X7 R9 20
30 5
7.5
F13
7
20
1
Fleet Management System, GND - X6/7 X8/1 - Door Open Driver Side Input X8 R6 10
R15 15
21
21
19
19
9
20 15 R10
10
Sleeper HVAC Fan Motor, GND - X7/1 X10/3 - Belt Buckle Contact Signal 20
Cabin HVAC Fan Motor, GND - X7/2
3
3 21
*Auxiliary Circulation Fan-Windshield, GND - X16/18 X21/8 - Alternator Charging, Feedback X51
1 4
3 6
3 21 X52
1
Ignition Controlled Pins - Turned on by FETs depending on ignition switch status, with three types, BAT, ACC, or IGN
Logic Controlled Outputs - Turned on and off by FETs depending on SAM inputs (from CAN and other input pins), interlocks and parameter settings. They
are unfused, but will turn off in the case of an over current. Not all are powered pins, some pins are turned on and off to a ground, and are noted by GND. 15 3 18 3 21 3 18 3
Ground Return Pins - Dedicated ground pins connected internally to the SAM GND. 13 1 16 1 19 1 16 1
Logic Controlled, Relayed, Fused Outputs - Fused and controlled by a relay depending on either ignition switch status or by inputs to the SAM. The Daimler Trucks, NA
control side of all the relays are fused through one fuse on each SAM.
Title: SAM Pin Layout - Wall Chart
Fused Passthoughs - Constant BAT power through a fuse X13 X12 X11 X10 Author: Andrew Lucas, SSD, TSD
STI-490 (11/07)