Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
BONDERITE® Alodine®
1446363 • • • • Tri-Chrome
M-CR 871 AERO 871
Ready- Use as
Liquid Amb
to-Use Received
BONDERITE® Alodine®
1445846 • • • • Hex-Chrome
M-CR 1132 AERO 1132
BONDERITE® M-CR 871 AERO Touch-N-Prep® Coating is a tri-chrome dry-in-place conversion coating
MIL-DTL-81706 Type 2 Class
designed for use on aluminum and its alloys. The applicator used to deliver this product provides an
1A and 3 approved and
easy and safer method of repairing bare areas of aluminum surfaces. Its proper use reduces worker
meets other major OEM
contact to chemical solutions and decreases wastewater, such as rinse water generated from a
qualifications
conversion coating process.
s
Ambient Until Dry
ed
MIL-DTL-81706 Type 1 Class BONDERITE® M-CR 1132 AERO Touch-N-Prep® Coating is designed to save labor, material, and time
1A and 3 approved and when applying a dry-in-place hex-chrome conversion coating for touch-up applications. Its p
roper
meets other major OEM use also reduces worker contact to chromated solutions and decreases wastewater, such as rinse
qualifications water generated from a chromating process.
Pen Instructions
Touch-N-Prep® pens are designed for easy and safer repair of clean, bare, or previously painted aluminum surfaces.
It is a non-rinse, dry-in-place application that can be applied using the following steps:
1 Before applying the coating, the treated surface must be cleaned using the following process:
• Use a moistened abrasive pad to remove oxides from the surface of the metal.
• Wipe substrate with a damp, lint-free cloth to ensure complete removal of soils and
dislodged oxides generated from the previous step.
• Allow surface to dry before Touch-N-Prep® application.
2 To activate, hold the Touch-N-Prep® pen 5 Allow the BONDERITE® M-CR 871
upright, pop off the cap and hold the pen AERO and BONDERITE® M-CR 1132
tip down onto a clean surface to begin AERO Touch-N-Prep® coating to air-
the flow of solution to the tip. Do not dry thoroughly.
twist or turn to remove the cap, since this
may result in the pen leaking.
3 Press the pen tip down on the surface 6 Frequent, short jabs to rewet the
until solution fills the pen tip. Apply application tip are preferred to
the BONDERITE® M-CR 871 AERO and maintain constant coating weights
BONDERITE® M-CR 1132 AERO solution to and avoid over-wetting the felt tip.
the metal surface with firm, smooth, even
strokes, covering all edges. Overlap each
stroke and allow to dry.
4 Within 5 minutes of the first coat, apply a 7 Always immediately replace the cap
second coat at a 90 degree angle to the first when not in use to avoid evaporation
coat with the same smooth, firm stroke. and contamination.