Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Service Manual
Auto-stitching and manual stitching
So that all the cameras in the series 4e scanners are seeing the image on a continuous line the
cameras are physically aligned at the production stage, but they also need an electrical alignment to
make sure that the image is correct. This is something that customers will need to carry out, and it
has been made a simple as possible to accomplish.
Ref.3.
Ref.1. Ref.2.
NOTE: All scanners have the centre arrow (Ref.1.) of the auto-stitch target lined up with the centre
arrow on scanner (Ref.3.)
EXCEPT the 4280e scanners where the seconded arrow (Ref.2.) lined up with the centre arrow on
scanner (Ref.3.)
5. Enter ScanWorks and in the ‘Data Control’ tab, click the Auto Stitch button.
NOTE: The 3640 scanner, being the only one with a single camera, can not be auto-
stitching.
If the Auto stitch targer is not available*, or the values need fine adjustment, carry out a manual stitch.
Using ScanWorks, under the 'Data Control' tab, run the manual stitch (under the ‘Auto Stitch’ button
shown on previous page). This will show the stitch values created using auto stitch. Pressing the
'Scan' button will automatically scan the target, displaying the image in ScanWorks. Zoom into the
correct ‘triangle’ on target by clicking 'View boundary 1' and ‘2’ in turn. Moving the image up or down,
look at the stitch points between the two cameras. If a discrepancy is see adjust the values by moving
the slider in either direction, remembering to adjust Front/Back stitch values first. Then re-scan to see
what difference has been made. Use the following to identify how to move the slider to achieve the
correct results.
Good Stitch.
Front/Back Left/Right
Then adjust the camera 2 / 3 stitch point (remembering cameras 1 / 2 have already been).
adjusted)
Increase Cam3 Decrease Decrease Increase Cam3
FB value Cam3 FB value Cam3 LR value LR value
* If the auto stitch target is not available, use a drawing with horizonal and diagonal lines similar to the
target to show the cross over areas of the cameras. See image of target on previous page. Note that the
make shift target does not need to have solid triangles to run the manual stitch.