Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
a. Remove all items except those on aircraft equipment list, drain fuel and hydraulic
fluids
b. Remove all items on the aircraft equipment list, drain fuel, compute oil and
hydraulic fluid weight
c. *Remove all items except those on the aircraft equipment list, drain fuel and fill
hydraulic reservoir
d. All of these
For flight equilibrium adequate restoring moment can be achieved by fixing C of G (Centre
of Gravity)
a) And C of P (Pressure) together b) Rear of C of P
*c) Front of C of P d) Along Aerodynamic C of P
The point on the chord line at which the total lift of a section at an aerofoil is considered to
act is known as
a) Centre of Gravity *b) Centre of Pressure
c) Lift d) None of the above
For flight equilibrium adequate restoring moment can be achieved by fixing C of G (Centre
of Gravity)
(a) end C of P (Pressure) together (b) rear of C of P
*( c) front of C of P (d) along aerodynamic C of P
Which of the following can provide the empty weight on an aircraft if the aircraft’s weight
and balance record become lost, destroyed or otherwise inaccurate
*(a) Re-weighing the aircraft (b) Aircraft specification
(c) Type certificate datasheet (d) Flight manual
Amount of fuel used for computing empty weight and corresponding C.G is
(a) Empty fuel tanks
*(b) Useable fuel
(c) The amount of fuel necessary for half hour of operation
(d) Full tank fuel
Two boxes which weigh 10 pounds and 5 pounds are replaced in an airplane so that their
distance from C.G are 4 feet and 2 feet respectively. How far forward of the C.G should
a third box weighing 20 pounds be placed so that the C.G will not be changed.
(a) 3 feet *(b) 2.5 feet (c) 3.5 feet (d) 8
feet
In third angle projection method, the top view is always above the ___________ view.
*(a) front (b) right side (c) left side (d) pop
In isometric projection, each of the three axes makes an angle of _____________ with the
other two.
(a) 60o (b) 90o (c) 180o *(d) 120o
For accurate location of particular area on an a/c, which of the following is necessary?
a) Water line
b) Butt line
c) *As in a) and b) in conjunction with station line
d) None