Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
NORTH HUB
JOB SAFET ANALYSIS Ref No.:
PROJECT
NIL
Rev No.: 1
Grinding, Welding & Gas cutting
Page: 1 of 4
Prepared by: JOE ZARAGOZA, SUPERVISOR Reviewed by: MARK ROGER HUBERIT II
Approved by: MARK ROGER HUBERIT II Date: 13-8-19
1 Work start-up Unauthorized work Obtain a hot work permit before starting the job PTW applicant
& obtaining Get the permit validated for the specific day Supervisor
PTW Invalid permit Supervisor must ensure that all work activities are PTW holder
carried out by competent personnel
Lack of competency Conduct Toolbox meeting, review the Method
statement and Job safety analysis to all craftsmen
Lack or poor involved in the work activities.
communication Responsible person will conduct inspection,
monitor the work activities and have to ensure
Haste or shortcut safety standards and procedures are strictly
adhered to.
2 Grinding Rotating equipment Make sure guards are fitted to all moving parts Supervisor
sparks. Ensure the proper use of guards
Damaged grinding Inspect the grinding discs prior to starting work
disc (ring test)
Make sure that disc is compatible with the
grinding machine
Check the RPM of disc & machine
Proper PPE (Gloves + Mask).
Electrocution. Correct installation of Grinder Wheel.
Gas monitor correctly sited.
High Pressure air
Spark containment to be used.
Project:
NORTH HUB
JOB SAFET ANALYSIS Ref No.:
PROJECT
NIL
Rev No.: 1
Grinding, Welding & Gas cutting
Page: 2 of 4
Step Description of Hazard Control Measures/ Responsible
No. Task Step Preventive Measures Person
Flying object/eye
injuries Only experienced personnel to use the equipment.
4 Welding Fire Hazard Before starting welding make sure the area is Supervisor &
clear of all types of combustible materials Workers
Burns. Provide a fire blanket on site
Make sure fire extinguishers are available on site
Wear proper PPE for welding ie., leather jackets,
Electrocution/ Gloves, welding goggles/welding mask,
Spatter burns Trained Fire Watch.
Gas Monitor correctly sited.
Project:
NORTH HUB
JOB SAFET ANALYSIS Ref No.:
PROJECT
NIL
Rev No.: 1
Grinding, Welding & Gas cutting
Page: 3 of 4
Step Description of Hazard Control Measures/ Responsible
No. Task Step Preventive Measures Person
Damage cable Certified Equipment and to be sited as near as
possible to work site.
Hot tabs end pieces Proper earthing of equipment.
of welding rods. Certified Welder.
Make sure spark containment is used such as a
Sparking welding hood/fire blanket.
Ensure that rod holder is in good condition.
Damage cable Ensure that forward and return cables are in good
working condition.
Use proper cable connector for extension.
If cables are crossing the road then ensure proper
UV rays protection.
The welder & the welder helpers must wear
welding goggles
Project:
NORTH HUB
JOB SAFET ANALYSIS Ref No.:
PROJECT
NIL
Rev No.: 1
Grinding, Welding & Gas cutting
Page: 4 of 4
I THEREFORE UNDERSTAND AND AGREE TO THIS PROCEDURE AND SAFETY MEASURE THERE IN AND FULLY AWARE OF MY DUTIES AND
RESPONSIBILITIES UNDERSIGNED MY NAME HERE TO AND FELLOW WORKERS AS FOLLOWS:
1 18
2 19
3 20
4 21
5 22
6 23
7 24
8 25
9 26
10 27
11 28
12 29
13 30
14 31
15 32
16 33
17 34
35