Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Caution: Warnings:
Use of this equipment in a manner other than specified by these This equipment is not designed for use in hazardous atmospheres or with
instructions may impair protection provided by the equipment. hazardous materials.
Mercury is a health hazard. Tighten capsule completely to prevent mercury
Indications for Use:
escaping during trituration. Immediately replace any capsule that becomes
WIG-L-Bug is designed for mixing dental amalgams and cements. worn or loose-fitting. Close safety cover during use.
Technical Specifications: Precautions:
Speeds: 3800 rpm-4800 rpm. 1. Carefully remove unit from packing material.
Capacity: Designed to use amalgam capsules with lengths between
2. Remove the red packing screws from bottom of the unit. Save the screws;
1.250⬙ and 1.350⬙.
should it ever become necessary to transport your WIG-L-BUG, the
Power Requirements: 115v ±10%, 0.5A, AC, 60 Hz. screws must be reinstalled to prevent damage in shipping.
Fuse Rating: 2 amps, 250 volts
䢇
1 Plug into grounded outlet. 䢇
5 Load capsule. Insert one end of capsule 䢇
6 Close safety cover H.
into holding arm, then push other end
䢇
2 Turn on power switch A. down to lock in place. Use only standard 䢇
7 Press F to start. Unit will automatically
stop when preset time expires. To stop at
䢇
3 Set time: Press E and adjust with B & C. amalgam capsules.
any time, press G.
Available range is from 0 to 30 seconds.
䢇
4 Set speed: Press D and adjust with B & C. 䢇
8 Turn off unit when not in use.
Four speeds are available: 3800, 4200,
4600 and 4800 RPM.
H 6
D 4
B
C E 3
2 7 F G
A
8
8.5⬙ x 11⬙, no bleed Z-fold height to 3.67⬙ 1 over 1 (Black) 24# smooth white uncoated stock
Step by Step Instructions • Model LPD
䢇
1 Plug into grounded outlet. 䢇
5 Load capsule. Insert one end of capsule Use only standard amalgam capsules. The
into holding arm, then push other end WIG-L-BUG LPD does not accept Fuji capsules
䢇
2 Turn on power switch A. down to lock in place. or any capsule with a tail or pouring spout.
䢇
3 Set time: Press E and adjust with B & C. 䢇
6 Close safety cover H.
Available range is from 0 to 30 seconds.
䢇
7 Press F to start. Unit will automatically
䢇
4 Set speed: Press D and adjust with B & C. stop when preset time expires. To stop at
Four speeds are available: 3800, 4200, any time, press G.
4600 and 4800 RPM.
䢇
8 Turn off unit when not in use.
H 6
5
2
A
8
D 4 B
E 3 C
7 F G