Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Air conditioning (often referred to as AC, A/C, or air con)[1] is the process of
removing heat and moisture from the interior of an occupied space, to improve
the comfort of occupants. Air conditioning can be used in both domestic and
and even to display and store some delicate products, such as artwork.
Air conditioners often use a fan to distribute the conditioned air to an occupied
space such as a building or a car to improve thermal comfort and indoor air
quality. Electric refrigerant-based AC units range from small units that can cool
installed on the roof of office towers that can cool an entire building.
air) and subterraneous pipes that can distribute the heated refrigerant to the
In the most general sense, air conditioning can refer to any form of technology
Air Requirement
Air requirement, abbreviated ACH or ACPH, is a measure of the air volume
volume of the space.[1] If the air in the space is either uniform or perfectly mixed,
air changes per hour is a measure of how many times the air within a defined
space is replaced.
period depends on the airflow efficiency of the enclosure and the methods used
to ventilate it. The actual amount of air changed in a well mixed ventilation
scenario will be 63.2% after 1 hour and 1 ACH.[2] In order to achieve equilibrium
pressure, the amount of air leaving the space and entering the space must be
the same.
Load estimation
stage of the project and goes on until almost the end of the project.
Full fuel load conditions with the stove operating at maximum power is one of
risk of using heat recovery devices under partial load conditions. Using the
stove models developed for the project, the fuel loads were varied to determine
the impact on both flue gas inlet temperature and flue heat loss.
On/off control
On-Off control is the simplest form of feedbackcontrol. An on-off
controller simply drives the manipulated variable from fully closed to fully
will turn on the heat when the process variable is below the set point and turn
it off when the process variable is above the set point. These controllers
normally include a delay, hysterisis and or a cycle time to reduce the cycling or
"hunting" when the process variable is close to the set point. In truth, they are
closer to thermostats than controllers, because they do not balance heat loss
Pipe works
construction system that's a new toy every day!". It was first designed by John
Choong
Valves and fitting
A valve is a device that regulates, directs or controls the flow of a fluid (gases, liquids, fluidized
solids, or slurries) by opening, closing, or partially obstructing various passageways. Valves
are technically fittings, but are usually discussed as a separate category. In an open valve, fluid
flows in a direction from higher pressure to lower pressure. The word is derived from the Latin
valva, the moving part of a door, in turn from volvere, to turn, roll. While fitting means Any
machine component, piping or tubing part that can attach or connect two or more larger parts.
For examples, see coupling, compression fitting, piping and plumbing fittings and pipe fitting.
Domestic Air-Condition
Home air conditioning systems come in several designs, ranging from large
central systems driven by outdoor compressors to small plug-in units that stand
on the floor or mount in a window. No matter what form they take, air
these work together to transfer heat and moisture from the inside of your home
to the outside.
Commercial Air-Condition
CITY MULTI Series VRF (Variable Refrigerant Flow) is Mitsubishi Electric's answer to energy efficient
large-scale air conditioning applications such as shopping centres, apartments, hotels, motels and
commercial sites. The CITY MULTI R2 & WR2 Series feature 2-pipe technology, providing simultaneous
heating and cooling.
air conditioning is a closed system in which a refrigerant is circulated through tubing and a variety of
components. The purpose is to remove heat from the aircraft cabin. While circulating, the refrigerant
changes state.