Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
*or appropriate Hole Wizard variables. One variable may be used in place of
another.
*Hole Wizard variables are in lower case letters, and have the form: <hw-type>
*The items in capital letters are SolidWorks symbol names, and have the form: <MOD-
DIA>
*
*New entries left of the = above will not be used.
*Deleting any entries left of the = above, may result in associated holes having
blank hole callouts.
*
*Valid Hole Wizard variables are as follows:
*VARIABLE DESCRIPTION*
*<hw-type> Type
*<hw-std> Standard
*<hw-fsttyp> Fastener Type
*<hw-fstsze> Fastener Size
*
*<hw-cbdepth> Counterbore Depth
*<hw-cbdia> Counterbore Diameter
*<hw-cdrlang> Counterdrill Angle
*<hw-cdrldepth> Counterdrill Depth
*<hw-cdrldia> Counterdrill Diameter
*<hw-csang> Countersink Angle
*<hw-csdia> Countersink Diameter
*<hw-depth> Depth
*<hw-diam> Diameter
*<hw-drlang> Drill Angle
*<hw-endcond> End Condition
*<hw-fscsang> Far Side Countersink Angle
*<hw-fscsdia> Far Side Countersink Diameter
*<hw-headclr> Head Clearance
*<hw-holedia> Hole Diameter
*<hw-holedepth> Hole Depth
*<hw-mjrdia> Major Diameter
*<hw-midcsang> Middle Countersink Angle
*<hw-midcsdia> Middle Countersink Diameter
*<hw-minordia> Minor Diameter
*<hw-nscsang> Near Side Countersink Angle
*<hw-nscsdia> Near Side Countersink Diameter
*<hw-tapdrldepth> Tap Drill Depth
*<hw-tapdrldia> Tap Drill Diameter
*<hw-threadang> Thread Angle
*<hw-threaddepth> Thread Depth
*<hw-threaddesc> Thread Description
*<hw-threaddia> Thread Diameter
*<hw-threadclass> Thread Class (1B, 2B or 3B, applies to Ansi Inch holes only)
*<hw-threadseries> Thread Series
*<hw-threadsize> Thread Size
*<hw-thruholedepth> Thru Hole Depth
*<hw-thruholedia> Thru Hole Diameter
*<hw-thrutapdrldp> Thru Tap Drill Depth
*<hw-thrutapdrldia> Thru Tap Drill Diameter
*
*<hw-descrp> Description
*
* Cosmetic thread callout variables
*
*<cthrd-std> Standard
*<cthrd-type> Type
*<cthrd-size> Size
*<cthrd-major-dia> Major Diameter
*<cthrd-minor-dia> Minor Diameter
*<cthrd-depth> Thread Depth