0%(1)Il 0% ha trovato utile questo documento (1 voto)
1K visualizzazioni7 pagine
The document provides instructions for removing and installing a Weistec 722.9 valve body in a transmission. Key steps include draining fluid, removing the pan and filter, disconnecting the valve body harness, removing bolts using a T30 bit while extending the gear selector linkage, and shipping the valve body for modification. Reinstallation involves lubricating O-rings, pressing the valve body into place, bolting it with a T30 bit, installing a new filter and pan gasket, refilling with transmission fluid.
The document provides instructions for removing and installing a Weistec 722.9 valve body in a transmission. Key steps include draining fluid, removing the pan and filter, disconnecting the valve body harness, removing bolts using a T30 bit while extending the gear selector linkage, and shipping the valve body for modification. Reinstallation involves lubricating O-rings, pressing the valve body into place, bolting it with a T30 bit, installing a new filter and pan gasket, refilling with transmission fluid.
The document provides instructions for removing and installing a Weistec 722.9 valve body in a transmission. Key steps include draining fluid, removing the pan and filter, disconnecting the valve body harness, removing bolts using a T30 bit while extending the gear selector linkage, and shipping the valve body for modification. Reinstallation involves lubricating O-rings, pressing the valve body into place, bolting it with a T30 bit, installing a new filter and pan gasket, refilling with transmission fluid.
Tools Required 3/8" Drive 6mm socket 3/8" Drive Ratchet T-30 Torx Bit E-10 Bit
Phone 877-WEISTEC Fax 888-516-8219
www.weistec.com 2 ______________________________________________________________________________ I. Valve Body Removal 1. Drain Transmission Fluid using a 6mm socket 2. Remove Transmission Pan using an E10 bit. Keep pan level as it will still have fluid in it. Once it has been removed, dump fluid into proper container and discard original Transmission Pan Gasket 3. Remove Transmission Oil Filter by gently pulling it off of the valve body. Discard used Transmission Oil Filter 4. Remove Valve Body Bolts using a T30 bit and extend gear selector linkage towards rear of transmission
Manually extend gear selector
linkage in direction indicated by the blue arrow (Towards rear of transmission)
Phone 877-WEISTEC Fax 888-516-8219
www.weistec.com 3 ______________________________________________________________________________ 5. Gently Press on the Valve Body Harness Connection as shown below while slowly removing Valve Body. IF CARE IS NOT TAKEN IN THIS STEP THE VALVE BODY MAY BE DAMAGED AND MAY NEED TO BE REPLACED
6. Properly Package Valve Body to prevent damage from shipment
7. Ship Valve Body to Weistec Engineering for modification
Phone 877-WEISTEC Fax 888-516-8219
www.weistec.com 4 ______________________________________________________________________________ II. Valve Body Installation
1. Lubricate O-Rings on Valve Body Harness Connection
2. Gently press Valve Body into place
3. Make sure Shift Linkage Pin is properly inserted into Plastic Linkage
Phone 877-WEISTEC Fax 888-516-8219
www.weistec.com 5 ______________________________________________________________________________ 4. Bolt in valve body using a T30 bit, torque to 7nm
5. Press on New Transmission Oil Filter
6. Affix New Transmission Pan Gasket 7. Bolt on Transmission Pan using an E10 bit 8. Fill transmission with new fluid using proper Mercedes procedure. Expect to use 5 to 6 liters of fluid.