Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
: 2100-8
Service DATE: 25 January 2016
Notice PAGE: 1 of 2
Periodic check/inspection of the Abrasion Strip bond integrity on Model 369/500/600 Helicopter Main
Rotor Blades is required in order to detect this condition if it occurs.
PURPOSE:
The purpose of this notice is to ensure the periodic check/inspection of the Abrasion Strip bond integrity on
Model 369/500/600 Helicopter Main Rotor Blades are carried out as required.
Failure to comply with this notice may result in dis-bond or delamination of the Main Rotor Blade Abrasion
Strip during operation. Loss of the Main Rotor Blade Abrasion Strip could result in significant vibration,
and potential loss of control of the aircraft.
2) Record all voids in regards to size and location in the helicopter log book and check each void prior to each
flight for growth and acceptable criteria as described in Chapter 62 Main Rotor, 62-10-00 Main Rotor
Blade, 7. Main Rotor Blade Leading Edge Abrasion Strip Check (Reference 1 - CSP-HMI-2, Reference 2 -
CSP-H-2, Reference 3 - CSP-H-4, Reference 4 – CSP-RLB, Reference 5 - HTCM-001).
3) Any blade exhibiting a void(s) outside of the acceptable criteria as described in Chapter 62 Main Rotor, 62-
10-00 Main Rotor Blade, 7. Main Rotor Blade Leading Edge Abrasion Strip Check shall be removed from
service until repaired into an airworthy condition (Reference 1 - CSP-HMI-2, Reference 2 - CSP-H-2,
Reference 3 - CSP-H-4, Reference 4 – CSP-RLB, Reference 5 - HTCM-001). In such case, please notify
Helicopter Technology Company (Contact below).
4) Corrosion Inspection every 100 Hours (Reference 5 - HTCM-001 and Reference 6 - SB 2100-4R2).
POINTS OF CONTACT:
For further information and rotor blade disposition, contact Helicopter Technology Company, LLC (HTC)
at (310) 523-2750, or FAX (310) 523-2745. www.helicoptertech.com