Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
(Pre-review Class)
Directions. In the Answer Sheet provided, shade the box of the letter that corresponds to your
answers. Pencil no. 2 should be used in marking your answers. Careless marking of your answer
sheet may lower the scores you earn on this test.
You will have FOUR (4) hours for this test. Work as rapidly and as accurately as you can. If
you are not sure of an answer, mark the choice which is your best guess. Only one answer should
be marked for each problem.
1. What section of PD 1570 IRR Article IV Code of Professional Ethics states “As a witness
before a court, commission, and/or tribunal, he shall express an opinion only when it is founded
on adequate and honest conviction.”
2. The quantity of a certain commodity that is offered for a sale at a certain price at a given place
and time.
A. Demand C. Stocks
B. Goods D. Supply
3. The Flight Standards Inspectorate Service (FSIS) of the CAA assists the Director General in
carrying out the responsibilities of his office for certification and ongoing inspections of aircraft,
airmen and air operators. Which of the following functions shall not be performed by the said
permanent office:
A. Airworthiness Inspection
B. Flight Operation and Evaluation
C. Personnel Licensing
D. None of the Above
4. As per Part 43 of the Federal Aviation Regulations, who among the following is not
authorized to perform maintenance, preventive maintenance, rebuilding, and alterations;
7. After the expiration of ___ years from the date of revocation or suspension of a certificate of
registration, the Board may, in its discretion and for reason it may deem meritorious, reinstate the
validity of a revoked or suspended certificate, or issue a new one in lieu of the one previously
revoked upon payment of the required fee.
A. 1
B. 2
C. 3
D. 4
8. That part of an aircraft which generates power mainly to produce the force or thrust necessary
to cause the aircraft to move horizontally, or to be lifted, or both a small fraction of the power
generated by the power plant is used to drive aircraft accessories and equipment, a propeller or a
rotary wing is not part of the powerplant.
10. Under Article I Section II of P.D. 1570 IRR, between the two (2) concentric circles along the
circumference of the seal shall be inscribed the words
___________________________________ and ________________________________ at the
upper and the lower portion of the circumference respectively.
A. 12 Months
B. 6 Months
C. 24 Months
D. 30 Months
A. Book Value
B. Salvage Value
C. Scrap Value
D. Going Value
A. Salvage Value
B. Scrap Value
C. Book Value
D. Going Value
14. How much must be deposited at 6% each year beginning on January 1, year 1 in order to
accumulate $5000 on the last deposit on Jan 1, year 6?
A. $756.22
B. $800
C. $705.81
D. $716.81
15. Who is responsible for maintaining the airworthy condition of the aircraft?
A. AMT
B. Pilot-in-Command
C. Owner or Operator
D. Authority
16. What category of a precision instrument approach and landing with a decision height lower
than 60m (200ft), but not lower than 30m (100ft), and runway visual range not less than 350m.
A. CAT I
B. CAT II
C. CAT IIIA
D. CAT IIIB
A. Line Manager
B. General Manager
C. Project Manager
D. Staff Manager
18. Find the compound amount if $2,500 is invested at 8% compounded quarterly of 5 years and
6 months.
A. $3964.95
B. $3578.89
C. $3864.95
D. $3764.95
20. What freedom has the right to carry passenger from Country A to Country B by stopping in
home country?
A. 7th
B. 8th
C. 6th
D. 5th
A. Reinstatement/Replacement of Certificate
B. Seal and its use
C. Posting Certificate
D. Meaning of Practice of Aeronautical Engineers
22. Which statement/s is true for Qualification for exemption from the Board Exam under PD
1570 IRR Article II. Sec. 4?
(1) Possess all qualifications under Section 14 and above
(2) Practice at least 5 years
(3) Supporting Papers under Article II Section 2
A. 1&3
B. 2&1
C. 3&2
D. 3
E. All of the Above
A. Sec. of DOLE
B. Sec. of Justice
C. Sec. Foreign Affairs
D. DGCA Chairman
A. 1200
B. 2000
C. 7500
D. 7600
E. 7700
26. Authorized to issue CPCN for Domestic and FACP for International
A. CAAP
B. Director General
C. Board
D. CAB
27. Who is the Accountable Manager of repair stations according to the FAR?
A. The person designated by the certificated repair station who is responsible for and has
the authority over all repair station operations that are conducted under part 145
B. The person in charge of the Quality system
C. The Chief Maintenance Officer
D. Always the President or the person who holds the highest position
28. An applicant for a standard Certificate of Airworthiness for an import aircraft type
certificated in accordance with Part 5 is entitled to a Certificate of Airworthiness if the country in
which the aircraft was manufactured or previously registered certifies, and the Authority finds,
that
A. The applicant presents evidence to the Authority that the aircraft conforms to a type
design approved under a type certificate or a supplemental type certificate and to the
applicable Airworthiness Directives of the State of Manufacture.
B. The aircraft has been inspected in accordance with the performance rules of this
regulation for inspections and found airworthy by persons Authorized by the
Authority to make such determinations within the last 30 calendar days.
C. The Authority finds after an inspection that the aircraft conforms to type design and is
in condition for safe operation.
D. All of the Abovc
29. FAA regulation requires a transport aircraft to carry ___ more fuel than needed on a flight for
45 minutes to observe airworthiness standard.
A. 10%
B. 20%
C. 15%
D. 25%
30. An airspace of defined dimensions established around an airport for the protection of airport
traffic (ref. PCAR)
31. In weighing of aircraft, a revised Load Data Sheet shall be issued before flight for airplanes,
when the empty weight has changed by more than one half of one percent of the maximum take-
off weight or 10 kg, whichever is the greater, or
A. the empty weight center of gravity position has changed by more than 2% of the
maximum permissible center of gravity range or 5 mm, whichever is the greater.
B. the empty weight center of gravity position has changed by more than 1% of the
maximum permissible center of gravity range or 10 mm, whichever is the greater.
C. the empty weight center of gravity position has changed by more than 2% of the
minimum permissible center of gravity range or 5 mm, whichever is the greater.
D. the empty weight center of gravity position has changed by more than 1% of the
minimum permissible center of gravity range or 10 mm, whichever is the greater.
32. In conformity with the conditions prescribed in the Articles of the Chicago Convention,
which of the following documents may not be carried by every aircraft of a Contracting State
engaged in international navigation
A. Guadalajara
B. Habana
C. Rome
D. Montreal
A. Joint Bond
B. Collateral Trust Bond
C. Equipment Obligation Bond
D. Registered Bond
35. “When free competition exists, the price of a product will be that value where supply is equal
to the demand”
A. Law of Demand
B. Law of Supply and Demand
C. Law of Diminishing Return
D. Law of Supply
36. “When one of the factors of production is fixed in quantity or is different to increase,
increasing the other factors of production will result in a less than proportionate increase in
output.”
A. Law of Demand
B. Law of Supply and Demand
C. Law of Diminishing Return
D. Law of Supply
A. In-place value
B. Break even
C. Balanced sheet
D. Check and Balance
38. If you borrowed $5000 from a friend with a simple interest of 12% per year. Find its worth
when it’s due after 7 months.
A. $5250
B. $5300
C. $5350
D. $5200
A. An asset
B. An expenses
C. An owner’s equity
D. A liability
41. FAR Part 23 category with 12,500 MTOW with 9 or less seating configuration and intended
for limited operations
A. Normal
B. Utility
C. Acrobatic
D. Commuter
A. Continuing Airworthiness
B. Design Organization
C. Production Organization
D. Training Organization Requirements
45. Which document provide detailed requirements that support the intent of a regulation
presented in a Part, but gain the force and effect of the governing regulations only if specifically
referred to in the governing regulation?
A. Implementing Standards
B. Advisory Circulars
C. Code of Federal Regulations
D. TCDS
46. There shall be a seal to be used by the Board authenticate its official documents. This seal
which shall be circular in shape with maximum diameter of _________
47. Based on FAR part 23, a single engine aircraft and multi-engine aircraft with a MTOW of
less than 6000lbs may not have a stall speed greater than ___ knot.
A. 60 C. 62
B. 61 D. 63
A. RA #7227
B. EO #193 s. 2003
C. EO #903 s. 1983
D. RA #6958
50. A type of signal when an aircraft is in grave and imminent danger and requires immediate
assistance.
1. B 26. D
2. D 27. A
3. D 28. D
4. B 29. B
5. A 30. A
6. C 31. A
7. B 32. A
8. C 33. B
9. A 34. B
10. C 35. B
11. C 36. C
12. B 37. B
13. C 38. C
14. D 39. A
15. C 40. A
16. B 41. B
17. D 42. B
18. C 43. C
19. E 44. A
20. C 45. A
21. B 46. A
22. E 47. B
23. D 48. C
24. C 49. D
25. C 50. A