Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page: 1/12
BASF Safety data sheet
Date / Revised: 20.01.2015 Version: 2.2
Product: HERBADOX 330 E
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
HERBADOX 330 E
Use: crop protection product, herbicide
Manufacturer/supplier:
BASF Philippines, Inc.
11/F HHIC Building, 1128 University Parkway,
North Bonifacio, Global City, Taguig, Metro Manila, PHILIPPINES
Telephone: +63 2 811-8000
Telefax number: +63 2 838-1025
Emergency information:
National emergency number:
+63 2 831 5576
International emergency number:
Telephone: +49 180 2273-112
2. Hazard identification
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
Pictogram:
Signal Word:
Danger
Hazard Statement:
Flammable liquid and vapour. Causes serious eye damage. May be harmful if swallowed. May be
fatal if swallowed and enters airways. May cause damage to organs through prolonged or repeated
exposure. May cause respiratory irritation. Very toxic to aquatic life. Very toxic to aquatic life with
long lasting effects.
Precautionary Statement:
If medical advice is needed, have product container or label at hand. Keep out of reach of children.
3. Composition/information on ingredients
Chemical nature
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
Hazardous ingredients
pendimethalin
Content (W/W): 33.7 % Acute Tox.: Cat. 5 (oral)
CAS Number: 40487-42-1 Skin Sens.: Cat. 1B
Aquatic Acute: Cat. 1
Aquatic Chronic: Cat. 1
xylene
Content (W/W): < 60 % Asp. Tox.: Cat. 1
CAS Number: 1330-20-7 Flam. Liq.: Cat. 3
Acute Tox.: Cat. 5 (Inhalation - vapour)
Acute Tox.: Cat. 5 (oral)
Skin Corr./Irrit.: Cat. 2
Eye Dam./Irrit.: Cat. 2B
STOT SE: Cat. 3 (irr. to respiratory syst.)
STOT RE (Auditory organ): Cat. 2
Aquatic Acute: Cat. 2
Aquatic Chronic: Cat. 3
calciumdodecylbenzenesulfonate
Content (W/W): < 5 % Skin Corr./Irrit.: Cat. 2
CAS Number: 26264-06-2 Eye Dam./Irrit.: Cat. 1
4. First-Aid Measures
General advice:
First aid personnel should pay attention to their own safety. If the patient is likely to become
unconscious, place and transport in stable sideways position (recovery position). Immediately
remove contaminated clothing.
If inhaled:
Keep patient calm, remove to fresh air, seek medical attention. Immediately administer a
corticosteroid from a controlled/metered dose inhaler.
On skin contact:
Immediately wash thoroughly with plenty of water, apply sterile dressings, consult a skin specialist.
Page: 4/12
BASF Safety data sheet
Date / Revised: 20.01.2015 Version: 2.2
Product: HERBADOX 330 E
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
On contact with eyes:
Immediately wash affected eyes for at least 15 minutes under running water with eyelids held open,
consult an eye specialist.
On ingestion:
Immediately rinse mouth and then drink 200-300 ml of water, seek medical attention. Do not induce
vomiting due to aspiration hazard.
Note to physician:
Symptoms: The most important known symptoms and effects are described in the labelling (see
section 2) and/or in section 11., Further important symptoms and effects are so far not known.
Treatment: Treat according to symptoms (decontamination, vital functions), no known specific
antidote.
5. Fire-Fighting Measures
Suitable extinguishing media:
water spray, carbon dioxide, foam, dry powder
Specific hazards:
carbon monoxide, carbon dioxide, nitrogen oxides
The substances/groups of substances mentioned can be released in case of fire.
Further information:
Collect contaminated extinguishing water separately, do not allow to reach sewage or effluent
systems. Dispose of fire debris and contaminated extinguishing water in accordance with official
regulations. In case of fire and/or explosion do not breathe fumes. Keep containers cool by spraying
with water if exposed to fire.
Environmental precautions:
Do not discharge into the subsoil/soil. Do not discharge into drains/surface waters/groundwater.
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
7. Handling and Storage
Handling
No special measures necessary if stored and handled correctly. Ensure thorough ventilation of
stores and work areas. When using do not eat, drink or smoke. Hands and/or face should be washed
before breaks and at the end of the shift.
Storage
Segregate from foods and animal feeds.
Further information on storage conditions: Keep away from heat. Protect from direct sunlight.
Storage stability:
Storage duration: 24 Months
xylene, 1330-20-7;
TWA value 100 ppm (ACGIHTLV)
STEL value 150 ppm (ACGIHTLV)
TWA value 0.1 mg/m3 (OEL (PH))
(OEL (PH))
Included in the regulation, but with no data values - See the regulation for
further details
Hand protection:
Suitable chemical resistant safety gloves (EN 374) also with prolonged, direct contact
(Recommended: Protective index 6, corresponding > 480 minutes of permeation time according to
EN 374): E.g. nitrile rubber (0.4 mm), chloroprene rubber (0.5 mm), butyl rubber (0.7 mm) etc.
Eye protection:
Tightly fitting safety goggles (splash goggles) (e.g. EN 166)
Page: 6/12
BASF Safety data sheet
Date / Revised: 20.01.2015 Version: 2.2
Product: HERBADOX 330 E
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
Body protection:
Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting
boots, chemical-protection suit (according to EN 14605 in case of splashes or EN ISO 13982 in case
of dust).
pH value: approx. 5 - 7
(CIPAC standard water D, 1 %(m),
approx. 20 °C)
Flash point: 32 °C
Evaporation rate:
not applicable
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
Partitioning coefficient n-octanol/water (log Pow):
not applicable
Other Information:
If necessary, information on other physical and chemical parameters is indicated in this section.
Thermal decomposition: 210 - 320 °C, 820 kJ/kg (DSC (OECD 113))
Substances to avoid:
strong oxidizing agents, strong bases, strong acids
Hazardous reactions:
No hazardous reactions if stored and handled as prescribed/indicated.
Acute toxicity
Of low toxicity after single ingestion. Virtually nontoxic by inhalation. Virtually nontoxic after a single
skin contact.
Experimental/calculated data:
LD50 rat (oral): 3,366 mg/kg
Irritation
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
May cause severe damage to the eyes. Not irritating to the skin.
Experimental/calculated data:
Skin corrosion/irritation rabbit:
Respiratory/Skin sensitization
Assessment of sensitization:
The product has not been tested. The statement has been derived from substances/products of a
similar structure or composition.
Experimental/calculated data:
Draize test human:
Assessment of mutagenicity:
The product has not been tested. The statement has been derived from the properties of the
individual components. Mutagenicity tests revealed no genotoxic potential.
Carcinogenicity
Assessment of carcinogenicity:
The product has not been tested. The statement has been derived from the properties of the
individual components.
Reproductive toxicity
Developmental toxicity
Assessment of teratogenicity:
The product has not been tested. The statement has been derived from the properties of the
individual components. Animal studies gave no indication of a developmental toxic effect at doses
that were not toxic to the parental animals.
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
Specific target organ toxicity (single exposure):
Repeated dose toxicity and Specific target organ toxicity (repeated exposure)
Information on: Solvent naphtha (petroleum), light arom.; Low boiling point naphtha - unspecified
Assessment of repeated dose toxicity:
Effects on the kidney of male rats were detected after repeated exposure. These effects are specific
for the male rat and are known to be of no relevance to humans. After repeated exposure the
prominent effect is local irritation. The product has not been tested. The statement has been derived
from substances/products of a similar structure or composition.
----------------------------------
Aspiration hazard
Ecotoxicity
EC50 (48 h) 7.73 mg/l, Daphnia magna (OECD Guideline 202, part 1, static)
Page: 10/12
BASF Safety data sheet
Date / Revised: 20.01.2015 Version: 2.2
Product: HERBADOX 330 E
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
----------------------------------
Mobility
Bioaccumulation potential
Additional information
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
Contaminated packaging:
Contaminated packaging should be emptied as far as possible and disposed of in the same manner
as the substance/product.
Sea transport
IMDG
Hazard class: 3
Packing group: III
ID number: UN 1993
Hazard label: 3, EHSM
Marine pollutant: YES
Proper shipping name: FLAMMABLE LIQUID, N.O.S. (contains XYLENE,
PENDIMETHALIN, SOLVENT NAPHTHA)
Air transport
IATA/ICAO
Hazard class: 3
Packing group: III
ID number: UN 1993
Hazard label: 3
Proper shipping name: FLAMMABLE LIQUID, N.O.S. (contains XYLENE,
PENDIMETHALIN, SOLVENT NAPHTHA)
EEC Directives:
Hazard symbol(s)
Xn Harmful.
N Dangerous for the environment.
R-phrase(s)
Page: 12/12
BASF Safety data sheet
Date / Revised: 20.01.2015 Version: 2.2
Product: HERBADOX 330 E
(30602025/SDS_CPA_PH/EN)
Date of print 21.01.2015
R10 Flammable.
R41 Risk of serious damage to eyes.
R48/20 Harmful: Danger of serious damage to health by prolonged exposure
through inhalation.
R65 Harmful: may cause lung damage if swallowed.
R50/53 Very toxic to aquatic organisms, may cause long-term adverse effects
in the aquatic environment.
S-phrase(s)
S2 Keep out of the reach of children.
S13 Keep away from food, drink and animal feeding stuffs.
S20/21 When using do not eat, drink or smoke.
S26 In case of contact with eyes, rinse immediately with plenty of water and
seek medical advice.
S29/35 Do not empty into drains, this material and its container must be
disposed of in a safe way.
S39 Wear eye/face protection.
S46 If swallowed, seek medical advice immediately and show this container
or label.
S57 Use appropriate container to avoid environmental contamination.
Other regulations
For the user of this plant-protective product applies: 'To avoid risks to man and the environment,
comply with the instructions for use.' (Directive 1999/45/EC, Article 10, No. 1.2)
Registration status:
Vertical lines in the left hand margin indicate an amendment from the previous version.
The data contained in this safety data sheet are based on our current knowledge and experience and
describe the product only with regard to safety requirements. The data do not describe the product's
properties (product specification). Neither should any agreed property nor the suitability of the product for
any specific purpose be deduced from the data contained in the safety data sheet. It is the responsibility
of the recipient of the product to ensure any proprietary rights and existing laws and legislation are
observed.