Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Pre-action
1) Notebook computer with Windows ver. XP or 7 (Windows 8 is not available)
2) Data cable
a) USB 2.0 Cable A(M)-B(M)
-. For connecting monitor & computer, this USB cable is same with Printer’s connect cable
b) USB to 8 pins cable
-.
è When you install new monitor, you have to move the switch from STOP to RUN as above photo.
3) Install USB to 8 pins driver
We attached this driver program(USB to 9 Pins driver.exe).
For install this program to your computer, please double-click “USB to 9 Pins driver.exe”
5) Please make sure the serial No. & model name of sterilizer which you want to install/re-install program.
3) go to “Options” à “Recipe”
4) Click “Open” of A window and go to B window and choose recipe.csv of USB and click “Open” of B window
and click OK of A window
A
B
2-3) Enter Password “2009” and check “Enable Limited Times as 5 & click OK
2-4) Enter Password “2009” and Click OK
2-7) Click OK
Then, might be installed as belows;
◆ If the sterilizer is double door system, please do Front & Back monitor as same as belows;
1) Delete Old Program(If the monitor is new one, it is no need to do this step)
--> Back monitor don’t need this step
1-1) On the monitor of Sterilizer, go to manual mode and press “Setting” and enter password
1-2) Press “System Menu”
2-3) Choose the model of Monitor (We have 4 Models of monitor such as DOP-B05S100,
DOP-B05S111,DOP-B07S515,DOP-B07E515)
2-4) Click “Compile” button
Then, the Program might be installed as belows;
After the install of program was finished, Power off. After 5 sec., please Power On for setting
3. Setting
2) Enter Password
3) Press “Setting” and enter Password
4) Go to Setting (1) and push the part(A) of Equipment Label & type the Serial No. of Sterilizer
A
5) press “TYPE” and choose the Model Name
6) If you want to use the sterilizer from the old sterilization data, you don’t need to do this step.
But, if you want to use the sterilizer from new(1 cycle), please set the cycle No. as belows;
Please push cell of Run Times & type the required cycle No. as 1 or 2 or 3,,,
After you do to here, Power Off. After 5 sec., Please Power ON.