Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
All rights reserved. No part of this document may be reproduced or issued to third parties in any form
whatsoever without the express permission of SATO. The materials in this document are provided for
general information and are subject to change without notice. SATO assumes no responsibilities for any
1. ANTENNA MODULE
A) Parts available in the Kit
N o. P arts N o. P arts N am e PC
1 K 00074020 R FID A N TEN N A -LF 1
2 H 00690010 A N TEN N A C A B LEL -LF 1
3 K 00247000 Flexible sheet-LF 1
4 JG 100291A N YLO N C LIP 2
5
② ③
3. Pass the antenna cable through the side opening as shown below and
assemble the antenna cover back.
2. RFID MODULE
a. Parts available in the kit
N o. P arts N o. P arts N am e PC
1 K00073010 R FID M O D U LE -LF 1
2 R 05728020 R FID C A B LE A S SY-LF 1
3 P 27049000 R FID M O D U LE B R A C K ET 1
4 P 30580000 SP A C ER (6) -LF 4
5 JG 100291A N YLO N C LIP 1
6 M A 0300422 P A N H EA D S C R EW 9
7 M D 4300822 P A N SC R EW +S W +W L 1
② ①
③
⑦
⑤
④ ⑥
CT4i RFID Kit Installation Guide
2. Remove the 2 screws as shown below before inserting the RFID Module
bracket.
CT4i RFID Kit Installation Guide
3. Once the RFID Module Bracket is in place, insert the screws at the 4
locations indicated by the red arrows below.
(b)
(a)
(b)
4. Connect the antenna cable to the RFID module using the connector at (a)
5. Connect the RFID Module to the printer main PCB using the cable (b)
6. Insert back the printer bottom cover
CT4i RFID Kit Installation Guide
3. RFID STICKER
a. Parts available in the Kit
N o. P arts N o. P arts N am e PC
1 Q 01738000 STIC KER (M O D U LE) 1
2 Q 01739000 STIC KER (P R IN TER ) 1
3 Q 01644000 S A TO R FID S O LU TIO N S STIC KER 1
b. Sticker position
① ②