Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Training Files:
Download the training files using the button below, if you have not done so already.
Download
Procedure Setup:
1. To avoid naming conflicts, it is recommended you save your work, click File > Close until no models
display, then click File > Manage Session > Erase Not Displayed.
2. Click File > Manage Session > Set Working Directory and navigate to the
PTCU\CreoParametric2\Cabling\Reroute_Wires folder and click OK
2. Select Appearances Manager from the Appearance Gallery types drop-down list.
5. Click Override all in the Warning message window, then click Close.
9. Click Modify Harness from the Harness group and click HARNESS_1 > Done from the menu
manager.
10. Select the blue W-2 wire, right-click, and select Reroute.
11. In the graphics window, select the first and third locations on the green and white wire path.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_6697620f-... 25-10-2017
Rerouting Wires Page 2 of 5
Figure 1
13. Select the Target tab from the Reroute cables dashboard.
◾ Select W-5 from the Use path of drop-down list.
◾ Notice that the path is now longer and follows the W-5 wire.
Figure 2
15. Select the blue W-2 wire in the mid-segment, right-click, and select Reroute.
16. Notice that only this segment portion of wire W-2, highlighted in cyan, is being rerouted.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_6697620f-... 25-10-2017
Rerouting Wires Page 3 of 5
Figure 3
Figure 4
18. Notice that, by default, all wires in the path, not just the blue, are being rerouted.
19. Select the Source tab from the Reroute cables dashboard.
◾ Clear the W-3 and W-4 check boxes.
Figure 5
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_6697620f-... 25-10-2017
Rerouting Wires Page 4 of 5
20. In the Source tab, select the W-3 and W-4 check boxes again.
Figure 6
22. Select the blue W-2 wire again, right-click, and select Reroute.
23. Select the Source tab and edit the Path type to Locations.
Figure 7
26. Select the Start and End locations of the black wire path.
Figure 8
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_6697620f-... 25-10-2017
Rerouting Wires Page 5 of 5
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_6697620f-... 25-10-2017