Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
rsf2 Page 1 of 4
SYSTEM CONFIG
System Frequency (50..60) 50Hz
Setting Dependencies (Disabled..Enabled) Enabled
Favourite Meters Timer (Off..60) 60min
Backlight timer (Off..60) 5min
Curr Set Display (xNom..Secondary) xNom
E/F Curr Set Display (xNom..Secondary) xNom
Select Grp Mode (Edge triggered..Level triggered) Edge triggered
Clock Sync. From BI (Disabled..Minutes) Disabled
Operating Mode (Out Of Service..Local Or Remote) Local Or Remote
Gn Unexpected Restart Blocking (Disabled..Enabled) Disabled
Setting Password (Password) NONE
Control Password (Password) NONE
Trip Alert (Disabled..Enabled) Enabled
General Alarm Alert (Disabled..Enabled) Enabled
Relay Identifier (16 Character String) ARGUS-M·7SR21···
Circuit Identifier (16 Character String) ················
CT/VT CONFIG
Phase Current Input (1..5) 1A
Phase CT Ratio Prim ( 6 Character String) 500···
Phase CT Ratio Sec (0.2..7) 1
Earth Current Input (1..5) 1A
Earth CT Ratio Prim ( 6 Character String) 500···
Earth CT Ratio Sec (0.2..7) 1
FUNCTION CONFIG
Gn Phase Overcurrent (Enabled..Disabled) Enabled
Gn Cold Load (Enabled..Disabled) Disabled
Gn Derived E/F (Enabled..Disabled) Disabled
Gn Measured E/F (Enabled..Disabled) Enabled
Gn Sensitive E/F (Enabled..Disabled) Disabled
Gn Restricted E/F (Enabled..Disabled) Disabled
Gn NPS Overcurrent (Enabled..Disabled) Disabled
Gn Under Current (Enabled..Disabled) Disabled
Gn Thermal (Enabled..Disabled) Disabled
Gn Line Check (Enabled..Disabled) Disabled
Gn CT Supervision (Enabled..Disabled) Disabled
Gn CB Fail (Enabled..Disabled) Disabled
Gn Broken Conductor (Enabled..Disabled) Disabled
Gn Trip Cct Supervision (Enabled..Disabled) Disabled
Gn Close Cct Supervis'n (Enabled..Disabled) Disabled
Gn Inrush Detector (Enabled..Disabled) Disabled
Gn CB Counters (Enabled..Disabled) Disabled
Gn I^2t CB Wear (Enabled..Disabled) Disabled
Gn Arc Flash Detector (Enabled..Disabled) Disabled
CURRENT PROT'N
PHASE OVERCURRENT
Gn 50 Measurement (RMS..Fundamental) RMS
Gn 51 Measurement (RMS..Fundamental) RMS
51-1
Gn 51-1 Element (Disabled..Enabled) Enabled
Gn 51-1 Setting (0.05..2.5) 0.89xIn
Gn 51-1 Char (DTL..ANSI-EI) IEC-NI
Gn 51-1 Time Mult (IEC/ANSI) (0.025..100) 0.06
Gn 51-1 Min Operate Time (0..20) 0s
Gn 51-1 Follower DTL (0..20) 0s
Gn 51-1 Reset ((IEC/ANSI) Decaying..60) 0s
51-2
Gn 51-2 Element (Disabled..Enabled) Disabled
50-1
Gn 50-1 Element (Disabled..Enabled) Disabled
50-2
Gn 50-2 Element (Disabled..Enabled) Disabled
MEASURED E/F
Gn 50G Measurement (RMS..Fundamental) RMS
Gn 51G Measurement (RMS..Fundamental) RMS
51G-1
Gn 51G-1 Element (Disabled..Enabled) Enabled
Gn 51G-1 Setting (0.005..1) 0.23xIn
Gn 51G-1 Char (DTL..ANSI-EI) IEC-NI
Gn 51G-1 Time Mult (IEC/ANSI) (0.025..100) 0.095
Gn 51G-1 Min Operate Time (0..20) 0s
Gn 51G-1 Follower DTL (0..20) 0s
Gn 51G-1 Reset ((IEC/ANSI) Decaying..60) 0s
51G-2
Gn 51G-2 Element (Disabled..Enabled) Disabled
50G-1
Gn 50G-1 Element (Disabled..Enabled) Disabled
50G-2
Gn 50G-2 Element (Disabled..Enabled) Disabled
CONTROL & LOGIC
MANUAL CB CONTROL
Gn Close CB Delay (0..900) 10s
Gn Blocked Close Delay (0..600) 5s
Gn Open CB Delay (0..900) 10s
Gn CB Controls Latched (Latch..Reset) Latch
Settings Editor ARGUS-M 7SR21 - 7SR210x-1xAxx-0CA0_BU_OHL PLTU 1.rsf2 Page 2 of 4
CIRCUIT BREAKER
Gn Close CB Pulse (0..20) 2s
Gn Reclaim Timer (0..600) 2s
Gn CB Control Trip Time (Disabled..Enabled) Enabled
Gn Trip Time Alarm (0..2) 0.2s
Gn Trip Time Adjust (0..2) 0.015s
Gn CB Travel Alarm (0.01..2) 1s
Gn Open CB Pulse (0.1..2) 1s
Gn CB DBI Delay (0..2) 0s
QUICK LOGIC
Quick Logic (Disabled..Enabled) Disabled
INPUT CONFIG
INPUT MATRIX
Inhibit 51-1 (35 Bit Binary) -----------------------------------
Inhibit 51G-1 (35 Bit Binary) -----------------------------------
Line Check (35 Bit Binary) -----------------------------------
Trig Trip Contacts (35 Bit Binary) -----------------------------------
Reset Trip Time (35 Bit Binary) -----------------------------------
General Alarm 1 (35 Bit Binary) -----------------------------------
General Alarm 2 (35 Bit Binary) -----------------------------------
General Alarm 3 (35 Bit Binary) -----------------------------------
General Alarm 4 (35 Bit Binary) -----------------------------------
General Alarm 5 (35 Bit Binary) -----------------------------------
General Alarm 6 (35 Bit Binary) -----------------------------------
General Alarm 7 (35 Bit Binary) -----------------------------------
General Alarm 8 (35 Bit Binary) -----------------------------------
General Alarm 9 (35 Bit Binary) -----------------------------------
General Alarm 10 (35 Bit Binary) -----------------------------------
General Alarm 11 (35 Bit Binary) -----------------------------------
General Alarm 12 (35 Bit Binary) -----------------------------------
General Alarm 13 (35 Bit Binary) -----------------------------------
General Alarm 14 (35 Bit Binary) -----------------------------------
General Alarm 15 (35 Bit Binary) -----------------------------------
General Alarm 16 (35 Bit Binary) -----------------------------------
General Alarm 17 (35 Bit Binary) -----------------------------------
General Alarm 18 (35 Bit Binary) -----------------------------------
General Alarm 19 (35 Bit Binary) -----------------------------------
General Alarm 20 (35 Bit Binary) -----------------------------------
CB Open (35 Bit Binary) -----------------------------------
CB Closed (35 Bit Binary) -----------------------------------
Reset Demand (35 Bit Binary) -----------------------------------
Reset Start Count (35 Bit Binary) -----------------------------------
Close CB (35 Bit Binary) -----------------------------------
Block Close CB (35 Bit Binary) -----------------------------------
Open CB (35 Bit Binary) -----------------------------------
E/F Out (35 Bit Binary) -----------------------------------
E/F In (35 Bit Binary) -----------------------------------
Trigger Wave Rec (35 Bit Binary) -----------------------------------
Trigger Fault Rec (35 Bit Binary) -----------------------------------
Select Group 1 (35 Bit Binary) -----------------------------------
Select Group 2 (35 Bit Binary) -----------------------------------
Select Group 3 (35 Bit Binary) -----------------------------------
Select Group 4 (35 Bit Binary) -----------------------------------
Select Group 5 (35 Bit Binary) -----------------------------------
Select Group 6 (35 Bit Binary) -----------------------------------
Select Group 7 (35 Bit Binary) -----------------------------------
Select Group 8 (35 Bit Binary) -----------------------------------
Out Of Service Mode (35 Bit Binary) -----------------------------------
Local Mode (35 Bit Binary) -----------------------------------
Remote Mode (35 Bit Binary) -----------------------------------
Local Or Remote Mode (35 Bit Binary) -----------------------------------
Clock Sync. (35 Bit Binary) -----------------------------------
Reset LEDs & O/Ps (35 Bit Binary) BI1
BINARY INPUT CONFIG
Inverted Inputs (19 Bit Binary) -------------------
BI 1 Pickup Delay (0..14400) 0.02s
BI 1 Dropoff Delay (0..14400) 0s
BI 2 Pickup Delay (0..14400) 0.02s
BI 2 Dropoff Delay (0..14400) 0s
BI 3 Pickup Delay (0..14400) 0.02s
BI 3 Dropoff Delay (0..14400) 0s
BI 4 Pickup Delay (0..14400) 0.02s
BI 4 Dropoff Delay (0..14400) 0s
BI 5 Pickup Delay (0..14400) 0.02s
BI 5 Dropoff Delay (0..14400) 0s
BI 6 Pickup Delay (0..14400) 0.02s
BI 6 Dropoff Delay (0..14400) 0s
BI 7 Pickup Delay (0..14400) 0.02s
BI 7 Dropoff Delay (0..14400) 0s
BI 8 Pickup Delay (0..14400) 0.02s
BI 8 Dropoff Delay (0..14400) 0s
BI 9 Pickup Delay (0..14400) 0.02s
BI 9 Dropoff Delay (0..14400) 0s
BI 10 Pickup Delay (0..14400) 0.02s
BI 10 Dropoff Delay (0..14400) 0s
BI 11 Pickup Delay (0..14400) 0.02s
BI 11 Dropoff Delay (0..14400) 0s
BI 12 Pickup Delay (0..14400) 0.02s
BI 12 Dropoff Delay (0..14400) 0s
BI 13 Pickup Delay (0..14400) 0.02s
BI 13 Dropoff Delay (0..14400) 0s
BI 14 Pickup Delay (0..14400) 0.02s
BI 14 Dropoff Delay (0..14400) 0s
BI 15 Pickup Delay (0..14400) 0.02s
BI 15 Dropoff Delay (0..14400) 0s
BI 16 Pickup Delay (0..14400) 0.02s
BI 16 Dropoff Delay (0..14400) 0s
BI 17 Pickup Delay (0..14400) 0.02s
BI 17 Dropoff Delay (0..14400) 0s
BI 18 Pickup Delay (0..14400) 0.02s
BI 18 Dropoff Delay (0..14400) 0s
Settings Editor ARGUS-M 7SR21 - 7SR210x-1xAxx-0CA0_BU_OHL PLTU 1.rsf2 Page 3 of 4