Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
CWP MOTOR
R UPPER AND
A LOWER
R BEARING
G
RPC-M
MNT-P1-ELD-W
WIN-005 Rev.00 1/8
OIL REPLA
ACEMENT
RAB
BIGH IWSPP
I PROJE
ECT
CW
WP MO
OTOR UPPER
U AND LOWER
L R BEAR
RING OIL
O
REPL
LACEMMENT
RPC
C-MNT--P1-ELD-WIN
N-005
Contents
Page:
We reserve all rights in this document and in the information contained therein. Reproduction, use or disclosure to third parties without
express authority is strictly forbidden.
1.0 Purpose
To provide the basic steps and procedure on the replacement of lubrication oil for the Circulating
Water Pump Motor upper and lower bearings.
2.0 Scope
Disassembly and reassembly procedure of motor accessories and its related auxiliaries for the
replacement of upper and lower guide bearing oil after the recommended running hours is meet.
Covers the inspection and cleaning of the upper bearing guide oil bath.
To specify the recommended torque values of each bolt after installation and tightening.
4.1 Abbreviations
CWP : Circulating Water Pump
LOTO : Lock Out Tag Out
4.2 Definitions
N/A.
5.0 Responsibilities
We reserve all rights in this document and in the information contained therein. Reproduction, use or disclosure to third parties without
express authority is strictly forbidden.
6.2 Re-assembly
25. CHECK inside and every details of the upper guide bearing oil bath, REMOVE
for foreign materials, tools and any other object.
26. INSTALL cover plate (11), TIGHTEN all cover plate bolts (10) at 500 N-m
torque.
27. CLEAN shaft before anti-rotation device (9) installation.
We reserve all rights in this document and in the information contained therein. Reproduction, use or disclosure to third parties without
express authority is strictly forbidden.
28. INSTALL and TIGHTEN all anti-rotation device bolts (7). Tighten at 500N-m
torque.
29. INSTALL circlip lock (8).
30. RE-ASSEMBLE anti rotation device cover (6).
31. INSTALL fan assembly (5). SECURE the fan assembly with circlip lock (4).
32. INSTALL fan housing assembly (3). Secure and fasten all bolts (2) of the fan
housing, apply anti-seize grease before installing bolts.
33. INSTALL breathing pipe (1).
34. REFILL 140 litres of TURBINE OIL ISO VG68 oil using the filling port (14).
35. REPAINT all motor surfaces with signs of scratch and rust.
8.0 Appendices
Appendices 1: Recommended list of Consumables and Materials
Appendices 2: List of Tools
9.0 Attachments
Attachment 1: CWP Motor Specification
Attachment 2: Motor Bearing Details Drawing.
Attachment 3: TMEIC Motor Catalogue
We reserve all rights in this document and in the information contained therein. Reproduction, use or disclosure to third parties without
express authority is strictly forbidden.
We reserve all rights in this document and in the information contained therein. Reproduction, use or disclosure to third parties without
express authority is strictly forbidden.
We reserve all rights in this document and in the information contained therein. Reproduction, use or disclosure to third parties without
express authority is strictly forbidden.