wat Errand pert eT UCC)
ain) beltel
for 2006-2015 VW Golf/GTI/Golf R, EOS, CC.
PAT RAM r et aio
cee s
SL ee ac CS
(Only For HRevision RCDS10) _-Various standard tools (Torx
-OEMTrunk handle camera withbits, screwdriver, soft pry tool,
Cores etc)
SCRE ee uno crc
Perro coy
Cece}
RSet a oe nec RR
of your battery before beginning. A VW GTI MKG is used in this
OMe eRe Cen oes
01 Remove the inner trunklid trim of your VW to gain access to,
its original emblem mounted trunklid actuator and wiring,
02- Unplug the connector from the existing badge. Then
ee eee eR cn
trunk lid. The existing badge can now be removed.
Cee ee Re)
assembly into the opening, and use the three torx screws
ee ee RCA Cc
shown in photo 03. Closeup is shown below.
04- Run the power and video signal wiring from the
CO CR RUS ee ae Rest Re ean
eran
Pegs ce RRS ee)
trigger wire down this grommet as well
i| 7 4 ed pat Ta Sete Cty
Ta) uide
TTT]
05-Tap the yellow trigger wire into the reverse lamp’s
12V+ wiring using a 18-22awg wire tap Se
Cre one ce eee eR)
the front of the vehicle. you will have to tuck these
pieces under trim panels, which can be pried off using
Boi pra
OVA ne. ee cee
CNSR
08-Connect the camera's power wire
CMa REC ead ad
tured). Locate an applicable fuse
(Fuse 24 used in this example)
ener Me een ag
ere Renae sey
fuse to fuse panel.2 Tet Ae cla)
J
erase)
Oren es Ce eC Rp Ta a ee M Ne eae 1)
ern es eee aed Aaa Ree cup ee aT: 3
Hide all wiring and re-install all removed trim panels,
10- Using VCDS, re-code your radio to enable rear view camera activation upen entering reverse
gear. Depending on which unit you are using, the VCDS steps will differ slightly.
Cea Ce enc end
-Go into Long Coding Editor/Helper
Sere ee ecm ee Re Re eee Renta |) ten ac
-Exit the long coding helper and ensure changes are saved. For the RNS510, Yeu Will need to reset
your device to activate your changes by pressing and holding eject+sun/moon GUIDE or
Cecersc nee ACRE Cece
ere eo ey faleicd
| [back comma ow thn Cn Me aed