Sei sulla pagina 1di 2

SAFETY PROCEDURES(OHS)

1. To prevent electrical shock hazard, disconnect the power cable from the
electrical outlet before relocating the system
2. When adding and removing devices to or from the system, ensure that the
power cables for the devices are unplugged before the signal cables are
connected. If possible, disconnect all power cables from the existing system
before you add a device
3. Make sure that your power supply is set to the correct voltage in your area
4. Before installing the Motherboard and adding a device on it, carefully read
the entire manual that came with the package
5. To avoid short circuits, keep paper clips, screws, and staples away from
connectors, slots, sockets and circuitry
6. Avoid dust, humidity, and temperature extremes. Do not place the product
in any area where it may become wet
7. Always ground or discharge yourself before touching any part of the
computer
8. Do not work alone so that there’s someone who can take care of you in case
of accident or emergency.
9. Be careful with the tools that may cause short circuit
10. Always full the cable connector on the handle and not on the cable itself
11. Use only rubber shoes when standing on the ground or in a concrete floor
12. Make sure that the pins are properly aligned when connecting a cable
connector.
13. Always power off and unplug the computer before working on it.
14. Take away any liquid such as mineral water or soft drinks near your
working area or near computers.
15. Contingency measures during workplace accidents, fire and other
emergencies are recognized.

SAFETY PRECAUTIONS

1. Do not place any combustible materials near the power outlet.


2. Avoid using power cord with defects such as loose contacts and
exposed conductors.
3. Avoid using connecting wires with exposed conductors.
4. Do all the wiring connection inside the computer system with the
power off.
5. Check the proper connections before turning the circuit power on.
6. Remove any jewelry, which is conductive.
7. Check your measuring instruments for proper voltage, current,
resistance setting before making any measurement.
8. Refer to the mother manuals for its proper jumper setting and
connection.

TOOLS NEDDED

1. Screwdriver
2. Piers and Tweezers
3. Flashlight
4. Chip Puller
5. Pickup Tools
6. Computer Vacuum Cleaner
7. Grounding Strap
8. Anti-Static Bags

STEP BY STEP IN DISASSEMBLING A COMPUTER SYSTEM UNIT

1. Discharge static electricity on your body by simply holding on any metal


substances.
2. Disconnect all external connections on your computer.
3. Disconnect all internal connections in you Central Processing Unit.
4. Unscrew all function cards like:
a. Video cards
b. NIC (Network Interface Card)
c. Sound card
d. Modem card
e. I/O card
5. Unscrew Floppy Drive.
6. Unscrew Hard Drive and CD-ROM Drive
7. Unscrew Motherboard.
8. Unscrew Power Supply.

Potrebbero piacerti anche