Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Preparation of Materials
The direct materials needed in the production of Chandelier/hanging bulbs shall be
glass/wine bottles, scrap metals, plywood, bulbs, socket and wire and wood screws.
Indirect materials such as bolt, glass cutter shall also be part of the product.
2. Filling of Bottles
Glass bottles shall be washed, after washing the glass bottles it shall be exposed to
3. Glass Cutting
Place each wine bottle upright on a flat, even surface. Use glass cutting tool to score the
perimeter of the bottle. Once completely score heat the line that you made. You can use a
small candle or butane torch. When you have spent around 3-5 minutes heating the bottle,
dip the end you are breaking off in cold water. Simply repeat the process of heating the
bottle and dipping in cold water until it snaps. Use a rough sandpaper to clean off the
Cut wood plank to size depending on the desired length of your wine bottle
chandelier and drill a holes for the bottles. But the base is metal, weld the scrap
metals in the desired shape. Test the fit of your bottles to ensure that they fit firmly.
Cut lamp wire with wire cutters into for the proper span needed between the socket
and the junction box which each socket will be screwed into. Attach each end of the
wire to the corresponding positive or negative screw located inside each socket
Insert light bulb into socket and ensure a level fit by placing sockets up inside of
each of the bottles. Repeat this step for all wine bottles.
Assemble all the bottles carefully to the wooden/metal base and set the wires in place.
1. Preparation of Materials
The direct materials needed in the production of glass bottle vase/holder shall be glass
bottle, paint or spray paint, glue and other decorating materials. Indirect materials such as
2. Filling of Bottles
Glass bottles shall be washed, after washing the glass bottles it shall be exposed to
3. Glass Cutting
Place glass bottle upright on a flat, even surface. Use glass cutting tool to score the
perimeter of the bottle. Once completely score heat the line that you made. You can use a
small candle or butane torch. When you have spent around 3-5 minutes heating the bottle,
dip the end you are breaking off in cold water. Simply repeat the process of heating the
bottle and dipping in cold water until it snaps. Use a rough sandpaper to clean off the
Use a paint to give life to the bottle and use different decorating materials to make unique
design.
Procedure Process for Glass Bottles Wind Chimes
1. Preparation of Materials
The direct materials needed in the production of glass bottle wind chimes shall be
glass bottles/wine bottle, jewelry chain, key rings, wooden wheel and pendant.
Indirect materials such as glass cutter, scissors etc. shall also be part of the product.
2. Filling of Bottles
Glass bottles shall be washed, after washing the glass bottles it shall be exposed to
direct sunlight and kept in a dry place.
3. Glass Cutting
Place glass bottle upright on a flat, even surface. Use glass cutting tool to score the
perimeter of the bottle. Once completely score heat the line that you made. You can
use a small candle or butane torch. When you have spent around 3-5 minutes heating
the bottle, dip the end you are breaking off in cold water. Simply repeat the process of
heating the bottle and dipping in cold water until it snaps. Use a rough sandpaper to
Lay the chain next to the bottle so that about 2” of the chain extends pas the bottom
cut end of the bottle. Attach the key ring to a chain. The key ring should just hang
gracefully. Line up the key at approximately the point on the bottle neck where it will
end up.
This wheel should be narrow enough to fit, diameter-wise, inside the widest part of
the bottle but wide enough to actually be able to hit the glass wall and make the
chime sound. Lift the wooden wheel about 1”-2” up from the bottom cut end of the
bottle.
down through the neck. Grasp the chin and gently flip the bottle over.