Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
555-565
Manuel Loza Murguía1§, Beatriz Choque Mamani2, Hilda Pillco Tancara2, David Huayta Tintaya2, Iván Chambi Osorio2 y Berta
Cutili Palero2
1
Departamento de Enseñanza e Investigación en Bioquímica & Microbiología. Unidad Académica Campesina Carmen Pampa. Universidad Católica Boliviana "San
Pablo". Coroico-Nor Yungas, La Paz, Bolivia. Tel. 591 2 2137293. 2Cátedra de Bioquímica y Microbiología. Módulo de Microbiología ambiental. Universidad Católica
Boliviana "San Pablo". §Autor para correspondencia: boliviamaloza@yahoo.com.
RESUMEN ABSTRACT
En los Yungas del departamento de La Paz, Bolivia se ubica In Yungas of department of La Paz, Bolivia is located the
la comunidad Carmen Pampa, fuente de recursos naturales community Carmen Pampas, source of natural resources
y biodiversidad exquisita, últimamente está siendo afectada and exquisite biodiversity, lately is being affected by the
por los chaqueos y actividades agrícolas convencionales, chaqueos and conventional agricultural activities, due
dado que no existen datos suficientes en la región para poder there is not enough data in the region to develop sustainable
desarrollar alternativas agrícolas sostenibles que cuiden el agricultural alternatives that take care of environment.
medio ambiente, de ahí que este trabajo tiene como propósito Taking this into account this work has as purpose to study the
estudiar el comportamiento de la lombriz roja californiana behavior of the californian red earthworm (Eisenia spp.) and
(Eisenia spp.) y la lombriz silvestre (Lumbricus spp.) en the wild earthworm (Lumbricus spp.) in two substrates with
dos sustratos a fin mejorar la calidad del vermicompost the aim to improve the quality of vermicompost produced by
producido por estos anélidos. El trabajo se ha realizado en these annelids. The work has been carried out in the module
el módulo de Microbiología Ambiental, en instalaciones of Environmental Microbiology, in facilities of Unidad
de la Unidad Académica Campesina Carmen Pampa Académica Campesina Carmen Pampa (UACCP), Campus
(UACCP), Campus Leahy, ubicado en Coroico Nor Yungas Leahy, located in Coroico Nor Yungas of Departamento
del Departamento de La Paz-Bolivia. Se ha estudiado su of La Paz-Bolivia. Their behavior has been studied in two
comportamiento en dos sustratos bosta bobina (estiércol) substrates bovine dung (manure) and bovine rumination
y rumia bovina (rumia) en 40 unidades experimentales de (rumination) in 40 experimental units of 0.2 m width*0.25
0.2 m de ancho∗0.25 m de largo∗0.4 m de profundidad, m length*0.4 m depth, each unit showed a density of 5,
cada unidad presentaba una densidad de 5, 10, 15, 20 y 25 10, 15, 20 and 25 individuals with two repetitions of each
individuos con dos repeticiones de cada una en 1 000 g de one in 1 000 g of substrate. The cocoons number, number
sustrato. Se determinó el número de cocones, número de of individuals at 8 weeks, and percentage of degradation
individuos a las 8 semanas, porcentaje de degradación del of the substrate was determined. The results indicate that
sustrato. Los resultados indican que los sustratos estiércol substrates manure is better in the population dynamics
son mejores en la dinámica poblacional de Eisenia spp., of Eisenia spp., in comparison with Lumbricus spp. The
en comparación con Lumbricus spp. Posiblemente las physical and chemical characteristics of manure and
características físicas y químicas del estiércol y la rumia rumination possibly influenced in this type of behavior
influyeron en este tipo de comportamiento de Eisenia spp. for Eisenia spp.
Palabras clave: Eisenia spp., Lumbricus spp., cocón, Key words: Eisenia spp., Lumbricus spp., cocoon,
densidad poblacional. population density.
INTRODUCCIÓN INTRODUCTION
En los Estados Unidos de América la cría de lombrices data In the United States of America earthworms breeding
desde unos 50 años, siendo la “lombriz roja californiana” exist since about 50 years ago, being the "californian red
denominación comercial: (red hibrid), la que revela mejores earthworm" commercial denomination: (red hibrid), the
condiciones para la cría en cautiverio (Ferruzi, 1987; one that reveals better conditions for breeding in captivity
Hernández, 1991; Lastra, 1995). (Ferruzi, 1987; Hernández, 1991; Lastra, 1995).
Las lombrices constituyen un recurso potencial de gran The earthworms constitute a potential resource of great
interés en la sostenibilidad de la agricultura, ya que interest in the sustainability of agriculture, since they actively
participan activamente en la regulación de las propiedades participate in regulation of the physical properties of the soil,
físicas del suelo, la dinámica de la materia orgánica del the dynamics of the organic matter of the environment and
entorno y el crecimiento de las plantas (Lavalle et al., 1999), the growth of plants (Lavalle et al., 1999), together with other
junto a otros organismos macrodescomponedores forman macro-converting organisms they are part of the soil fauna.
parte de la fauna del suelo. Esto se debe a su capacidad de This is due their capacity to decompose organic matter, to
descomponer la materia orgánica, reciclar nutrientes y la recycle nutrients and soil formation (Raty and Huhta, 2004),
formación de suelo (Raty y Huhta, 2004), actividad que activity that can be affected in presence of toxic elements in
puede ser afectada en presencia de elementos tóxicos en el the soil (Spurgeon et al., 1994).
suelo (Spurgeon et al., 1994).
The red earthworm (Eisenia spp.) is part of the current
La lombriz roja (Eisenia spp.) forma parte de las herramientas biotechnical tools for recycle of organic waste, obtaining
biotecnológicas actuales para el reciclaje de desechos as benefit the vermicompost (organic fertilizer) and meat,
orgánicos, obteniéndose como beneficio el vermicompost optimum source for animal feeding (Ferruzzi, 1987).
(abono orgánico) y carne, fuente óptima para la alimentación This annelid characterized to be hermaphrodite can end
animal (Ferruzzi, 1987). Este anélido caracterizado por ser up producing big quantities of earthworms per year, the
hermafrodita puede llegar a producir grandes cantidades de fertilizer product of their faeces contains a great bacterial
lombrices por año, el abono producto de sus deyecciones population (2*1012 bacteria g-1), developing its biological
contiene una gran riqueza bacteriana (2∗1012 bacterias g-1), cycle in small spaces (50*103 cm3 of substrate), it adapts
desarrollando su ciclo biológico en pequeños espacios to a wide range of edaphic-climate conditions (Flores and
(50∗103 cm3 de sustrato), se adapta a un amplio rango de Alvira, 1988).
condiciones edafoclimáticas (Flores y Alvira, 1988).
The red earthworm (Eisenia ssp.) is well developed under
La lombriz roja (Eisenia ssp.) se desarrolla a temperatura low average temperatures of 30°C (Edwards and Bater, 1992;
de 30°C (Edwards y Bater, 1992; Reinecke et al., 1992; Reinecke et al., 1992; Hernández et al., 1997; Hernández
Hernández et al., 1997; Hernández y Loa, 1998; Hernández and Loa, 1998; Hernández et al., 1999; Hernández 1997;
et al., 1999; Hernández 1997; Hernández et al., 2000), y en Hernández et al., 2000), and in a wide range of agricultural
diversos restos agrícolas, que permite utilizarla en condiciones remains, which allows to use it under warm climatic
climáticas cálidas, para el reciclaje de estiércoles y restos de conditions, for the recycle of manures of animals and crop
cosecha para la producción de humus de lombriz y proteína remains for the production of earthworm humus and animal
animal con la subsiguiente disminución de la contaminación. protein with the subsequent decrease of the contamination.
Comportamiento de lombriz roja californiana y lombriz silvestre en bosta bovina y rumia bovina como sustrato 557
En un hábitat de temperatura, humedad, pH, vitaminas In a habitat of appropriate temperature, humidity, pH,
y nutrientes apropiados, este invertebrado crece y se vitamins and nutrients, this invertebrate grows and
reproduce aceleradamente, si se compara con otros reproduces fast, if it is compared with other soil organisms
organismos del suelo (Satchell, 1983). En la actividad (Satchell, 1983). In the agricultural activity the use of the
agrícola el uso del vermicompost, produce en los cultivos vermicompost, produces in the cultivations important
mejoras importantes en su productividad y sanidad. Algunas improvements in its productivity and sanity. Some
investigaciones han demostrado que las aplicaciones investigations have demonstrated that the applications of
de este material en combinación con otros fertilizantes this material in combination with other fertilizers increase
incrementan a absorción de nutrientes, la producción to absorption of nutrients, the net production of high-
neta de cultivos prioritarios (trigo, arroz y caña) y priority cultivations (wheat, rice and cane) and it drastically
disminuye drásticamente la pérdida de nitrógeno del decreases the loss of nitrogen of soil by volatilization (Zhao
suelo por volatilización (Zhao y Fun-Zhen, 1992). and Fun-Zhen, 1992).
En la naturaleza, el principal enemigo de las lombrices es In the nature, the main enemy of the earthworms is the
el humano, pues el uso indiscriminado de agroquímicos human, because the indiscriminate use of agrochemicals
envenena su hábitat, ocasionando el empobrecimiento del poisons its habitat, causing the decay of soil and its
suelo y su consecuente infertilidad. Para las lombrices de consequent infertility. For breeding earthworms the danger
cría el peligro en el medio natural, se encuentra centrado in the natural medium, it is centered in insects, birds and
en insectos, pájaros y aves de corral. Sin embargo, se ha corral birds. However, it has been demonstrated that the
demostrado que la presencia de biocidas, inclusive en biocides presence, even in very low concentrations, produce
concentraciones muy bajas, producen una mortalidad a high mortality (Satchell, 1983).
elevada (Satchell, 1983).
The elements of manure (nitrogen and phosphorus),
Los elementos del estiércol (nitrógeno y fósforo), su materia its organic matter, silts, pathogens, heavy metals,
orgánica, sedimentos, patógenos, metales pesados, hormonas, hormones, antibiotics and ammonium can contribute to the
antibióticos y amonio pueden contribuir a la contaminación contamination of water and soil that can be dangerous for the
del agua y suelo que pueden ser peligrosas para la salud del human's health, animals and plants (Andriulo et al., 2003).
humano, animales y plantas (Andriulo et al., 2003).
The aim of this study is to improve the quality of the
El propósito de éste estudio fue mejorar la calidad del vermicompost produced by the annelid, behavior of
vermicompost producido por el anélido, se ha estudiado su Californian red earthworm and of the wild earthworm in
comportamiento de la lombriz roja californiana y la lombriz the dung substrates and bovine rumination at small scale has
silvestre en los sustratos de bosta y rumia bovina a pequeña been studied, because in the area there is no information due
escala, dado que en la zona no hay información dadas sus its edaphic-climatic characteristic.
características edafoclimáticas.
de longitud oeste. La distancia de la ciudad de La Paz a The area shows a precipitation of 2.185 mm, a yearly
Carmen Pampa es de 123 km (INE-MDSP-COSUDE, average temperature of 17 ºC, a maximum of 22 ºC, being
1999). the average minimum of 13 ºC. (experimental station
Carmen Pampas 1996-2005), belongs to the forest humid
La zona presenta una precipitación de 2.185 mm, una tropical pre-mountain type with a relative humidity of 75%
temperatura promedio anual de 17º C, una máxima de (Holdridge, 1987).
22º C, siendo la mínima promedio de 13º C. (estacional
experimental Carmen Pampa 1996-2005), pertenece al Material bovine dung and bovine rumination (substrate)
tipo bosque húmedo premontano tropical con una humedad
relativa de 75% (Holdridge, 1987). The dung or manure of bovine, were obtained of the bovine
module of the Veterinary Medicine and Zootecnia Faculty,
Material bosta bovina y rumia bovina (sustrato) Campus Manning, this washed with drinkable water in a
relationship 1:2, in order to eliminate urea and to regulate
La bosta o estiércol de bovino, se obtuvo del módulo pH until approximately near neutral value. The rumination
bovino de la Carrera de Medicina Veterinaria y Zootecnia, was obtained from the bovine of the slaughterhouse of the
Campus Manning, este se lavó con agua potable en una town of Coroico, the same as the previous one it was washed
relación 1:2, a fin de eliminar la urea y regular el pH hasta taking advantage of this waste to evaluate the adaptation of
aproximadamente cerca al neutro. La rumia se obtuvo de los earthworms.
bovinos del matadero de la localidad de Coroico, al igual que
el anterior se procedió al lavado aprovechando este desecho Biological material
para evaluar la adaptación de las lombrices.
Three thousand californian earthworms (Eisenia spp.) were
Material biológico used, of juvenile status that were provided by the module
of vermicompost of Agronomic Engineering Faculty. 300
Se utilizaron 300 lombrices californianas (Eisenia spp.), wild earthworms were captured (Lumbricus spp.) of the hill
juveniles, que fueron proporcionadas por el módulo de Uchumachi.
lombricultura de la Carrera de Ingeniería Agronómica. Se
capturaron 300 lombrices silvestres (Lumbricus spp.) del The samples in study were washed with distilled water, then
cerro Uchumachi. were weighed and individually placed in test tubes 180*10
mm in substrate, during one week in order to evidence
Los especímenes en estudio fueron lavados con agua the presence or not of cocones (earthworm eggs), those
destilada, luego se les peso y colocó individualmente en individuals exempt of these were used for this investigation.
tubos de ensayo 180∗10 mm en su sustrato, por lapso de
una semana a fin de evidenciar la presencia o no de cocones Experimental unit
(huevos de lombriz), aquellos individuos exentos de estos
fueron utilizados para esta investigación. The test was done in 40 units (oil drums) 0.2 m wide, 0.25
m long and 0.4 m depth that conformed a single structure
Unidad experimental of blocks, roofed and covered with milimetric mesh in the
top of each unit.
El ensayo se realizó 40 unidades (bidones de aceite) 0.2
m de ancho por 0.25 m de largo y 0.4 m de profundidad, Each unit has been identified with the acronym (T) for
que conformaban una sola estructura de bloques, techado treatment and its correlative numeration from 1 to 5 (T1),
y cubiertos con malla milimétrica en la parte superior de (T2), (T3), (T4), and (T5), with two repetitions that contained
cada unidad. 1 000 g of sustrato, 20 with bovine dung and Eisenia spp.,
20 with rumination and Lumbricus spp., to each unit it was
Cada unidad se ha identificado con la sigla (T) de tratamiento placed respectively 5, 10, 15, 20, and 25 previously weighed
y su numeración correlativa de 1 al 5 (T1), (T2), (T3), individuals with an AND scale with sensibility 0.01g. Also
(T4), y (T5), con dos repeticiones que contenían 1 000 g de two units were kept free of earthworms, one with bovine
sustrato, 20 con bosta bovina y Eisenia spp., 20 con rumia dung and another with rumination as control (Figure 1).
Comportamiento de lombriz roja californiana y lombriz silvestre en bosta bovina y rumia bovina como sustrato 559
La Figura 3 muestra la relación del peso de la población Figure 2 shows populational density of Eisenia spp. in bovine
de Eisenia spp, en bosta bovina con relación a la densidad dung with relationship to cocoone production (capsules), in the
poblacional en la unidad experimental, se observa que experimental unit, as observed in the graph this relationship is
su peso va disminuyendo paulatinamente a medida que proportional, and it is strongly associated this process in
aumenta la densidad, esto indica que el alimento es una 98.3%, which indicates that in the unit the reproduction was
condicionante para que el peso del individuo se vea afectado. not affected, coinciding with results from Hernández (1997
and 1999). Although Gutiérrez (2007) indicates that there
Hernández (1997 y 1999) observó que la composición was mortality in the first three days in fresh ovine manure, in
de algunos alimentos (sustratos) utilizados, permiten la composting manure of bovine where shown bigger cocones
cría con éxito de Eisenia spp. bajo diferentes condiciones number, results that agree with those obtained in this work.
560 Rev. Mex. Cienc. Agríc. Vol. 1 Núm. 4 1 de octubre - 31 de diciembre, 2010 Manuel Loza-Murguía et al.
Figura 2. Número de cocones de Eisenia spp. a ocho Figure 4 shows relationship of percentage of degradation
semanas en bosta bovina. of bovine dung in relation to density of individuals
Figure 2. Number of cocones of Eisenia spp. at eight weeks (Eisenia spp.) in the experimental unit, as observed, this
in bovine dung. is proportional to the number of individuals in 96.4% at
8 weeks, which means that these individuals carry out
degradation of the substrate without taking into account
25 the decrease of weight. The results are similar to those of
Hernández (1997, 1999), Gutiérrez (2007), Mamani (2005),
20 although these authors use different densities of earthworms
in their evaluations, these data are similar.
Peso de lombrices (g)
15
39
10 y= -0.435x + 26.52
37 R2= 0.964
y= -0.405x + 21.9
Degradación (%)
5 R2= 0.745 35
33
0
0 10 20 30 31
Densidad de lombrices 29
las 8 semanas, lo que quiere decir, que sin tomar en cuenta la that affinity of this species for this substrate is big, it also
disminución de peso estos individuos realizan la degradación seems that the optimum is 10 individuals per kg of sustrato
del sustrato. Los resultados son similares a los de Hernández to maintain an optimum weight. Some authors suggest that
(1997, 1999), Gutiérrez (2007), Mamani (2005), aunque the weight is in relation to the substrate type.
estos autores utilizan diferentes densidades de lombrices en
sus evaluaciones, éstos datos están próximos.
400
development.
80
Degradación (%)
se lograría economizar mano de obra y agua al compostear similar to Mamani (2005); Hernández (1999); Toccalino
el estiércol, obteniendo finalmente el impacto positivo et al. (2004), then this experiment is within pH values
(ambiental, social y económico). proposed by these authors.
Cuadro 1. Relación de valores del potencial de hidrogeniones (pH) de Eisenia spp. y Lumbricus spp. en los sustratos
bosta y rumia bovina a ocho semanas.
Table 1. Relationship of pH values of Eisenia spp. and Lumbricus spp. in the substrates dung and bovine rumination
at eight weeks.
AGRADECIMIENTOS In the rumination all the wild earthworms perish and there is
no increase in the cocoons number similar to the californian
one. Practically, their degradation capacity of the manure
Al módulo de lombricultura por proporcionar los is minimum, as long as the rumination does not degrade it.
especímenes para éste trabajo. Así como al laboratorio de
suelos para realizar esta actividad y al Ing. Ramiro Ochoa, The substrates of manure are better in the population
por realizar la revisión de los datos. dynamics of Eisenia spp, in comparison with Lumbricus
spp. possibly due the physical and chemical characteristics
of the manure; on the other hand, the rumination influenced
LITERATURA CITADA in this type of behavior of Eisenia spp.
Andriulo, A.; Sasal, C.; Améndola, C. y Rimatori, F. 2003. End of the English version
Impacto de un sistema intensivo de producción de
carne vacuna sobre algunas propiedades del suelo
y del agua. INTA. Argentina. 32(3):27-56.
Edwards, C. y Bater, J. 1992. The use of earthworms in
environmental management. Soil Bio. Biochem. Hernández, J.; Ramírez, N.; Bracho, B. y Faria, A. 1999.
24:1683-1689. Caracterización del crecimiento de la lombriz roja
España Ganadera. 1985. La lombriz estabulada. Vet. Arg. (Eisenia ssp), bajo condiciones de climas cálidos.
2:808-809. Maracay, Colombia. Rev. Fac. Agr. 25:139-147.
Ferruzzi, C. 1987. Manual de lombricultura. Mundi Prensa. Holdridge, R. 1987. Ecología basada en zonas de vida.
Madrid, España. 138 p. Instituto Interamericano de Cooperación para la
Flores, M. T. and Alvira, P. 1988. The earthworm (E. foetida Agricultura (IICA). San José, Costa Rica. 94 p.
Sav. and L. rubellus Hoff.). Biology and uses. An. Instituto Nacional de Estadística-Ministerio de Desarrollo
Edaf. Agrobiol. 7(8):771-778. Sostenible-Agencia Suiza para el Desarrollo y la
Gutiérrez, E. 2007. Dinámica poblacional de la lombriz Cooperación (INE-MDSP-COSUDE). 1999. Un
Eisenia foetica en estiércol composteado y fresco mundo de potencialidades. Atlas estadístico de
de bovino y ovino. Revista electrónica de veterinaria municipios. La Paz, Bolivia. 64 p.
(RERVET). 8(7):1-8. Lastra, E. 1995. Lombrices californianas, transformadoras
Hernández, I. 1991. Lombricultura en Escuela Agrotécnica de desechos. Rev. Acaecer. 20:10-12.
de General Cabrera. Rev. Acaecer. 17:16-20. Lavelle, P.; Brussaard, L. and Hendrix, P. 1999. Earthworm
Hernández, J. 1997. Observaciones preliminares del efecto manegement in tropical agroecosystemes. CABI
de la temperatura sobre la reproducción de la Publishing. Oxon y New York, USA. 300 p.
lombriz roja (Eisenia ssp.). VII Jornadas Científico Mamani, G. 2005. Comportamiento de la lombriz (Eisenia
Técnicas de la Facultad de Agronomía. 91 p. spp.) bajo dos ambientes y con residuos sólidos en
Hernández, J. y Roa, L. 1998. Efecto de tres estiércoles la zona de Carmen Pampa. Tesis de Licenciatura.
animal en la capacidad de reproducción de Universidad Católica Boliviana San Pablo. Coroico
la lombriz roja Eisenia ssp. Acta Científica Nor Yungas, La Paz, Bolivia. 100 p.
Venezolana. 49:209-215. Motalib, A. y Rida, A. 1982. Los gusanos de tierra y el medio
Hernández, J.; Paz, M. y Valera, S. 2000. Efecto de los restos ambiente. Rev. Mundo Científico. 14:408-415.
vegetales en la alimentación de la lombriz roja Räty, M. and Huhta, V. 2004. Earthworm communities in
(Eisenia ssp.), bajo condiciones de clima cálido. birch stands with different origin in Central Finland.
XVI Reunión Latinoamericana de Producción Pedobiología. 283-291 p.
Animal. Montevideo, Uruguay. 28 p. Reinecke, A.; Viljoen, S. y Saayman, R. 1992. The suitability
Hernández, J.; Rincón, M. y Jiménez, R. 1997. of Eudrilus eugeniae, Perioniy excavatus and
Comportamiento de la lombriz roja (Eisenia Eisenia fetida (Oligochaeta) for vermicomposting
fetida) bajo condiciones de clima cálido. Revista in Sourthern Africa in terms of their temperature
de la Facultad de Agronomía de LUZ. 14:387-392. requirements. Soil Biol. Biochem. 24:1295-1307.
Comportamiento de lombriz roja californiana y lombriz silvestre en bosta bovina y rumia bovina como sustrato 565
Satchell, J. E. 1983. Earthworm ecology from Darwing to Toccalino, P. A.; Agüero, M. C.; Serebrinsky, C. A. y Roux,
vermiculture. Chapman & Hall, Nueva York, USA. J. P. 2004. Comportamiento reproductivo de lombriz
485 p. roja californiana (Eisenia foetida) según estación del
Spurgeon, D. J.; Hopkin, S. P. and Jones, D. T. 1994. Effects año y tipo de alimentación. Rev. Vet. 15(2): 65-69.
of cadmium, copper, lead and zinc on growth, Yague, J. L. 1987. La crianza de la lombriz roja. Ministerio
reproduction and survival of the earthworm Eisenia de Agricultura, Pesca y Alimentación. Madrid,
foetida (Savigny): assessing the environmental España, 12 p.
impact of point-source metal contamination in Zhao, S. W. and Fun-Zhen, H. 1992. The nitrogen uptake
terrestrial ecosystems. Environmental Pollution. efficiency from N15 labelled chemical fertilizer in the
123-130 pp. presence of earthworm manure (cast). In: Veeresh,
Storer, T.; Usinger, R.; Stebbins, R. and Nybakken, J. 1986. G. K.; Rajagopal, D. and Viraktamath, C. A. (eds).
Zoología General. Sexta edición. Edit. Omega. Advances in management and conservation of soil
Barcelona. 955 p. fauna. New Dehli, India. 539-542 pp.