Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The work of bending reinforcement bars is carried out after cutting jobs
Its uses a hand bending tool which is placed on the table.
Tables must be long enough to put a long bar reinforcement.
If the bar is too long, then the two bending devices are used.
Bar bending is done slowly to avoid capillary cracking.
For large diameter bars, it should be heated first.
For the high yield bar, it cannot be heated before bending.
METHOD OF SORTING, TIE SPACING
AND STEEL INSTALLATION
After the cutting bar, tie bar work fine with the wire.
It purposes for avoid movement, especially when the
concreting work in progress.
The wire bonding used a diameter of 0.8mm to 1.6mm.
CONNECTION METHOD
Lap joint
Butt joint
Fillet joint
CONNECTION FOR POLE :
THE BEST OF CONNECTION TO BE MADE IN 1/3 THE HEIGHT
OF THE PILE.
CONNECTION OF BEAM :
THE CONNECTION OF BEAM SHOULD BE FORMED ¼ DISTANCE BEAM FROM BOTH END.
MOORINGS :
OCCURS WHEN CONNECTING BUILD TWO SECTIONS OF REINFORCED CONCRETE
WHICH BAR IS SERVED IN THE OTHER.
EXAMPLE ; BETWEEN THE PILLARS AND BEAM OR BETWEEN THE BASE OF THE
COLUMN.
TYPE OF
REINFORCEMENT
• Reinforcement bar
i. mild steel round bar
ii. High tensile deformed bar
iii. High yield deformed bar
• Reinforced steel mesh
i. Hexagonal wire mesh
ii. Welded wire mesh
iii. framework
RELATE THE BINDING SPACING IN
REINFORCEMENT INSTALLATION
• Reinforcement was installed according to engineering drawing that are
attached to a building
• It is important to ensure that the reinforcement has concrete cover
• Steel is bound with gauge iron faster 16 or 18
• This iron fasteners are used for stabilize and facilitate the placement of the
reinforcement wire
• In the CP 110, we can know the requirement in the design of reinforcement
structure
• All bending shall be made in accordance with engineering drawing
tolerance is 25%
• The sorting and spacing reinforcement :
• o Reinforcement shall be placed in the point where the maximum stress is
located such as below the structure surface.
• o This is because the inclusion of reinforcement can be lead a bar to rust
and this will weaken the bond with concrete.
• o The distance from the concrete surface to reinforcement (known as
“concrete cover”) is between 15mm to 40mm.