Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Preparation Supply
All surfaces should be grit blasted to meet the requirements Nitocote EPS has a shelf life of 12 months if kept in a dry
o o
of SA 2½ , First Quality or equivalent. store between 5 C and 30 C in the original, unopened
containers.
The lining work should be programmed so that newly
Storage conditions
cleaned steel is coated as soon as possible before the
formation of rust or scale. o
Store in dry conditions at temperatures between 5 C and
o
Priming 30 C in the original, unopened containers. If stored at high
temperatures the shelf life may be reduced.
Priming is not required for concrete and steel surfaces when
using Nitocote EPS on a dry, sound, well prepared Precautions
substrate.
Health and Safety
Mixing
Nitocote EPS and Fosroc Solvent 102 should not come in
The entire contents of the hardener can should be added to contact with skin and eyes, or be swallowed. Ensure
the base container and mixed thoroughly until a uniform adequate ventilation and avoid inhalation of vapour. Some
colour and consistency are obtained, taking particular care people are sensitive to resins and solvents. Wear suitable
to scrape the sides and bottom of the container. It is protective clothing, gloves and eye/face protection. Barrier
recommended that mechanical mixing be employed using a creams provide additional skin protection. Should
Jiffy mixer or a slow speed electrical drill. accidental skin contact occur, remove immediately with a
resin-removing cream, followed by soap and water. Do not
Application use solvent. In case of contact with eyes, rinse immediately
with plenty of clean water and seek medical advice. If
Once mixed, Nitocote EPS should be immediately applied to swallowed, seek medical attention immediately do not
surface ensuring a continuous coating of uniform thickness induce vomiting.
is obtained.
Fire
Stiff nylon brush or short nap roller is recommended for
such application. Fosroc Solvent 102 is flammable. Keep away from sources
of ignition. No smoking. In the event of fire, extinguish
Faster rates of application are possible using airless spray with CO2 or foam. Do not use a water jet.
equipment.
Flash points
Cleaning
Nitocote EPS: Non-flammable
Nitocote EPS should be removed from tools and equipment Fosroc Solvent 102: o
32 C
with Fosroc Solvent 102* immediately after use. Cured
material can only be removed mechanically. For further information, refer to the Product Material Safety
Data Sheet.
Nitocote EPS
Additional Information
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no di rect
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
Fosroc Jordan
Regional Offices: email: enquiryjordan@fosroc.com
Head Office
P.O Box 253, Amman-Khalda Offices: Tel: (06) 535 9562 Fax: (06) 535 9563
King Abdullah II Industrial State Amman-Sahab Factory: Tel: (06) 402 2665 Fax: (06) 402 9475
Sahab 11512, Jordan Aqaba Showroom: Tel: (03) 205 0061 Fax: (03) 205 0062
www.fosroc.com