Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Issue 06
Date 2015-03-30
and other Huawei trademarks are trademarks of Huawei Technologies Co., Ltd.
All other trademarks and trade names mentioned in this document are the property of their respective holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and the customer.
All or part of the products, services and features described in this document may not be within the purchase scope or
the usage scope. Unless otherwise specified in the contract, all statements, information, and recommendations in this
document are provided "AS IS" without warranties, guarantees or representations of any kind, either express or
implied.
The information in this document is subject to change without notice. Every effort has been made in the preparation
of this document to ensure accuracy of the contents, but all statements, information, and recommendations in this
document do not constitute a warranty of any kind, express or implied.
Website: http://www.huawei.com
Email: support@huawei.com
Contents
1 Introduction ..................................................................................................................................... 3
1.1 Appearance ....................................................................................................................................................... 3
1.2 Physical Ports ................................................................................................................................................... 4
1 Introduction
The RRU3804 is an outdoor remote radio unit. It is a RF module of the distributed NodeB
and is installed close to the antenna.
The RRU3804 performs modulation, demodulation, data processing, and combination and
division of baseband signals and RF signals.
1.1 Appearance
The DC-type RRU3804 is available in two appearances, as shown in Figure 1-1 and Figure
1-2. The AC-type RRU3804 is shown in Figure 1-3.
RRU3804 Figure 1-4, Figure 1-5, Figure 1-6, Table 1-1 and Table 1-2 illustrate ports on the
panel of the RRU3804.
2 Technical Specifications
2.2 Capacity
Table 2-3 RRU3804 capacity
Module Capacity
RRU3804 It supports four carriers.
As recommended in 3GPP TS 25.104, the receiver sensitivity (full band) is measured in the entire
operating band at the antenna connector on the condition that the channel rate is 12.2 kbit/s and the BER
is not higher than 0.001.
*: Measurement value of the sub-band at 850 MHz.
The maximum output power equals the maximum output power of the PA minus the internal losses.
The maximum output power is measured at the antenna connector of the RF module.
The output power per carrier in the output power table provides the maximum output power possible
while ensuring the network performance.
In 3 x4 configurations, the typical and maximum power consumption are reached when the output
power per carrier at the antenna connector is 15 W.
In the 3x1 or 3x2 configuration, one WBBPb4 and one WMPT are configured.
In the 3x3 or 3x4 configuration, two WBBPb4 units and one WMPT are configured.
In 3 x4 configurations, the typical and maximum power consumption are reached when the output
power per carrier at the antenna connector is 15 W.
In the 3x1 or 3x2 configuration, one WBBPb4 and one WMPT are configured.
In the 3x3 or 3x4 configuration, two WBBPb4 units and one WMPT are configured.
In 3 x4 configurations, the typical and maximum power consumption are reached when the output
power per carrier at the antenna connector is 15 W.
In the 3x1 or 3x2 configuration, one WBBPb4 and one WMPT are configured.
In the 3x3 or 3x4 configuration, two WBBPb4 units and one WMPT are configured.
Item Specification
Quantity of CPRI ports 2
CPRI Line Bit Rate RRU3804 modules of different BOM codes support different
CPRI data rates:
RRU3804 modules of 02315927, 02316116, 02315970,
02315467, 02316203, and 02316863 support only 1.25
Gbit/s.
RRU3804 modules of other BOM codes support both 1.25
Gbit/s and 2.5 Gbit/s.
Topology Star, chain, or ring
Item Specification
Cascading capability When optical modules with a port speed of 1.25 Gbit/s are
used:
Four levels are supported.
When optical modules with a port speed of 2.5 Gbit/s are
used:
Eight levels are supported.
Maximum Distance Single-level cascading: 40
from the BBU (km) Multiple-level cascading: 100
Item Specification
Input power –48 V DC, voltage range: –36 V DC to –57 V DC
200 V AC to 240 V AC single phase, voltage range: 176 V AC to 290 V
AC
100/200 V AC to 120/240 V AC two phases, voltage range: 90/180 V
AC to 135/270 V AC
Item Specification
Dimensions (H x W x DC RRU3804
D) − 480 mm x 270 mm x 140 mm (without the housing)
− 485 mm x 285 mm x 170 mm (with the housing)
AC RRU3804
− 480 mm x 270 mm x 220 mm (without the housing)
− 485 mm x 285 mm x 250 mm (with the housing)
Weight DC RRU3804
− Without housing: 15 kg
− With housing: 17 kg
AC RRU3804
− Without housing: 20.5 kg
− With housing: 22.5 kg
Item Specification
Operating temperature –40°C to +50°C (with 1120 W/m2 solar radiation)
–40°C to +55°C (without solar radiation)