Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
You can find out about our cookies and how to disable cookies in our Privacy
Policy. If you continue to use this website without disabling cookies, we will assume you are happy to receive them. Close.
Types of floor
Contents
[hide]
1 Introduction Featured articles and news
2 Solid ground floor
3 Suspended timber floor
bsi consultation
4 Suspended concrete floor
5 Ribbed floor
6 Hollow pot floor
7 Raised floor
8 Plenum
9 Floating floor
10 Sprung floor
11 Separating floor
12 Related articles on Designing Buildings Wiki
12.1 External resources
According to Approved Document C, a floor is the 'lower horizontal surface of any space in a
Notre Dame conservation
building, including finishes that are laid as part of the permanent construction.'
Structural support for the contents of the room, its occupants, and the weight of the floor
itself.
Resistance to the passage of moisture, heat and sound.
A surface finish which may contribute to the look, feel and acoustics of a space.
Very broadly, floor construction tend to be solid floors, built up from the ground, or suspended
floors, supported by wall structures. There are a very wide range of variations around these
basic types. The intended use of the floor, its location, the structure of the rest of the building,
and the required floor finish will determine which of the many variations is most suitable for a
particular application.
Solid floors tend to require little maintenance and are less prone to movement. They are often
built up from the following components: Rebuilding could take 20 to 40 years.
The thicknesses of the layers and their order will depend on the specific use required and the
ground conditions.
A suspended timber floor is usually constructed using timber joists suspended from bearing
walls, which are then covered with either floorboards or some other for of boarding material.
The joists are typically laid across the shortest span.
Ventilation may be provided to the void between the floor and the ceiling below by placing air
vents/air bricks within the exterior walls, allowing air to travel from one side of the building to
the other. This can, however, cause a problem of draughts, which can be avoided by installing
an airtight breather membrane which will help maintain an airtight seal.
RSHP’s high-rise residential towers win a tall
buildings award for excellence.
Suspended concrete floor
Other solutions include pre-cast concrete planks or pre-cast concrete beams with concrete
blocks laid between them. Voids can be created by beams or ribs, or cast-in holes, to house
services, as well as providing support for suspended or attached ceilings.
Larger beams allow a greater span, but require greater overall depth and more complex
formwork and reinforcement.
BSRIA study reveals strong growth in 2018.
Ribbed floor
Quality in Construction Summit
Ribbed floors use narrow-spaced shallow beams, or ribs, rather than wide-spaced deep
beams. Troughed floors are ribbed in only one direction, whereas coffered or waffle floors are
ribbed in two directions.
Ribbed floors have greater span and load potential per unit weight than flat slab construction.
This is a ribbed cast in situ floor with permanent formwork in the form of hollow clay or concrete
pots. This creates a flat soffit, allowing the direct application of a plaster finish or dry lining. The Dame Judith Hackitt confirmed as keynote
pot voids can be used to contain small diameter services within the overall slab depth. The speaker – one year on from the Hackitt Report.
most common form is a one way spanning floor, although two-way spanning is also possible.
Save £100 on tickets.
Raised floor
Ethics and professionalism
A raised floor (sometimes referred to as an access floor or raised access floor) is a floor
created above a solid floor slab, leaving an open void between the two. This void can be used
to distribute building services. Raised floors are often found in offices, or in spaces that have a
high demand for information and communications infrastructure such as data centres.
Plenum
Plenums are air compartments or chambers, either above suspended ceilings, in the gap
between the ceiling and the floor slab, or below raised floors in the gap between the raised
floor and the floor slab. They form part of the ventilation system for the building.
Modern slavery in the construction sector.
Contract law
Floating floor
A floating floor is a floor that is not fixed to the layer beneath it. Floating floors are particularly
common in refurbishment works, and can be used to help improve the thermal or acoustic
insulation of a floor construction.
Sprung floor
Sprung floors are used for activities such as dance, indoor sports, and multi-purpose halls
where specific properties of shock absorption and energy return are desirable to reduce the
What to bear in mind when claiming damages in
occurrence of injuries that may result from repeated impact or falls. They can also help
construction.
maximise performance.
Separating floor
The term ‘separating floor’ is generally used to describe a floor designed to restrict the passage
of sound between the spaces above and below. It is most commonly used in relation to
residential buildings.
Blinding.
How do we achieve sustainable clean-water
Coal holes, pavement lights, kerbs and utilities and wood-block paving.
Compartment floor. infrastructure for all?
Floating floor.
Floor definition.
Floor insulation. Appointments
Floor loading.
Flooring defects.
Floors of the great medieval churches.
Floor slab.
Insulation for ground floors.
Plenum.
Raised floor.
Separating floor.
Sistering floor joists.
Slab.
Sprung floor.
Suspended ceiling.
Types of flooring.
External resources
‘Building Construction Handbook’ (6th ed.), CHUDLEY, R., GREENO, R., Butterworth- What you should know when appointing an
Heinemann (2007). architect.
Standards
Share Add a comment Send us feedback
Design
Infrastructure