Sei sulla pagina 1di 4

PARTING SURFACE DEFINITION

PARTING
The parting surface of a mould are
SURFACE those portions of both mould plates,
adjacent to the impressions, which
BY
butt together to form a seal and
Y. HIDAYATHULLAH, prevent the loss of plastic material
TECHNICAL OFFICER – CAD/CAM, from the impression.
CIPET – MYSORE.

PARTING SURFACE 1. FLAT PARTING SURFACE


CLASSIFICATION

1.Flat Parting Surface


2.Non-Flat Parting Surface
a.Stepped Parting Surface
b.Profiled Parting Surface
c.Angled Parting Surface

1. FLAT PARTING SURFACE 1. FLAT PARTING SURFACE

1
2. NON-FLAT PARTING SURFACE 2. NON-FLAT PARTING SURFACE
a. Stepped Parting Surface b. Profiled Parting Surface

2. NON-FLAT PARTING SURFACE COMPLEX EDGE FORMS


c. Angled Parting Surface

COMPLEX EDGE FORMS COMPLEX EDGE FORMS

2
COMPLEX EDGE FORMS COMPLEX EDGE FORMS

BALANCING OF MOULD SURFACES BALANCING OF MOULD SURFACES


1. The plastic material when under pressure with in the
impression, will exert a force which will tend to open the
mould in the lateral direction (x). If this happens some flashing
may occur on the angled face. The movement between the
two mould halves will be resisted by the guide pillars, but
even so, because of the large forces involved, it is desirable
to balance the mould by reversing the step as in fig. b so that
the parting surface continues across the mould as a mirror
image of the section which includes the impression.
2. It is often convenient to specify an even number of impression
when considering this type of mould, as impressions
positioned on opposite sides of the mould’s centre-line serve
to balance the mould.
3. When balancing is not possible, due to size, then very sturdy
guide pillars must be incorporated.

RELIEF OF PARTING SURFACES RELIEF OF PARTING SURFACES


The injection pressure (pressure exerted by Actual pressure exerted within the impression
the plastic melt) is theoretically calculated will be considerably less than this theoritical
using the following formula, value for the following reasons;
P= F/A 1.The melt is non Newtonian.
Where, 2.The viscosity of the melt progressively
P = Theoritical Injection pressure, increases as it passes through the mould
due to cooling.
F = Force applied (N or lbf)
3.The actual pressure within the impression
A = Area of the injection ram (m2 or in2) depends on the length of the flow path.

3
RELIEF OF PARTING SURFACES RELIEF OF PARTING SURFACES
 To safeguard against very high opening forces
 In practice a value for the effective being developed due to flash, the parting
injection pressure of between 25% to 45% surface adjacent to the impression and runner is
of the theoretical is used, depending on bedded down on a relatively small area. The
the material and on the wall section of the remainder of the surface in the vicinity is relieved
moulding. to a depth of at least 2.4 mm.
 The small area adjecent to the impression and
 It is generally desirable that the clamping runner is termed the land.
force exceeds the opening force by atleast  The land width, ie. The distance between the
15%. impression and the relief, is normally made
between 5 mm to 25 mm depending on the
shape and complexity of the impression.

RELIEF OF PARTING SURFACES VENTING


 When plastics material enters an impression air is
displaced. Normally the air can escape between the two
mating mould plates. If the mould plates have a very fine
finish, the air may be trapped within the impression so
that mould defects, such as discoloration, sinks,
incomplete filling, etc. can develop.
 It is good design practice to provide vents in the mould to
allow air to escape freely.
 The vent is normally a shallow slot, not more than 0.05
mm (0.002 in) deep by 3 mm (1/8 in) wide, machined in
the land.
 If a greater depth is adopted there is the likelihood of
plastic material passing through the slot and the flash
mark will occur on the mouldings.

VENTING

Positions where a vent is likely to be


required are;
1. At the point furthermost from the gate
on symmetrical mouldings. THANK YOU
2. At the point where flow paths are likely
to meet
3. At the bottom of the projections

Potrebbero piacerti anche