Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1 из 1
Checking function and voltage supply
– Fold rear seat bench forwards.
– Remove cover under bench seat.
– Briefly operate starter. Fuel pump must be heard to run.
– Switch off ignition.
If the fuel pump does not run:
– Pull 4-pin connector off fuel delivery unit flange.
– Connect diode test lamp -V.A.G 1527- with
auxiliary cables from -V.A.G 1594- to outer
contacts of connector.
– Switch on ignition; LED must light up for
approx. 2 seconds.
If LED does not light up
– Check activation of fuel pump relay and
wiring for open circuit and short circuit
→ Current flow diagrams, Electrical fault
finding and Fitting locations.
If LED lights up (voltage supply OK):
– Remove fuel delivery unit → Chapter.
– Check that the electrical wiring between
flange and fuel pump is connected and has
continuity.
If no open circuit can be found:
– Renew fuel delivery unit → Chapter
vw-wi://rl/V.en-GB.K00510081.wi::34692676.xml?xsl=3 21.11.2018