Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Gravity lron
USER MANUAL
Iron Installation & Operation
Circuit Diagrams
T.F T.S
V : Voltage
P S/W : Power Switch
S S/W R
S S/W : Steam Switch
E.G : Earth Ground
V H SOL.V : Solenoid Valve
T.F : Over-Temperature
Fuse
SOL.V T.S : Temperature Setting
E.G L R : Resistance
L : Lamp
P S/W H : Heater
2
Gravity lron
Important Notice
Do not place iron upright direction when not in use. (See following figure)
How to operate
1. After iron temperature is sufficiently heated, open water tank valve, and
press the steam switch. (Press for 1~2 seconds and pause for 3~4 seconds.
Repeat, pressing 1~2 seconds then resting 3~4 seconds.)
Press the steam switch this way when you need steam.
2. Start ironing.
3. Do not press steam switch continuously longer than 5~6 seconds for a proper steam function.
4. Select the number of temperature control knob according to corresponding
temperature/ clothes which is following:
# 1, 2 --------- Pre-heating
# 3 ----------- Silk or sensitive clothes (low temperature)
# 4 ----------- Cottons and wool (medium temperature)
# 5 ----------- Other thick clothes (high temperature)
5. Cover ¡°Iron Shoe¡± to iron to get a better ironing effect without glossy to the clothes after ironing.
6. Please keep flammable materials away from the iron during ironing because temperature
of iron plate is very hot (over 200℃). Also, place the iron over silicon plate when not in use.
7. Always remove the power plug from socket when not in use.
of iron plate is very hot (over 200℃). Also, place iron over silicon plate when not in use.
8. Always remove power plug from socket when iron is not in use.
Self-Check Points
4
Gravity lron
Option Items
부품 리스트
Instruction
It is able to solve the clogged steam
problem by clearing the clogged steam
hole using steam hole pin as shown in
the figure at the right side.
Caution
Iron’s bottom may be very hot. Be careful
not to touch iron’s bottom while cleaning.
Usage
As shown in the figure at the right side,
open the solenoid valve in the iron using spanner and replace steam switching rubber
or valve spring, and reassemble it to solve this problem.
Caution
Be sure to assemble according to the sequence in the figure after replacing steam
switching rubber or valve spring. It may not work properly if the assemble sequence
is nor followed.
14
HEAD OFFICE & FACTORY
EUNSUNG ELECTRIC CO.,LTD
104-5,SHINPYUNG-RI,SHINBUK-MYON, POCHUN-SI, KYUNGGI-
DO,KOREA
TEL: 82-31-531-8131~6 FAX : 82-31-531-8130
E-MAIL:EUNSUNG5@KORNET.NET
www.silverstar.co.kr