Sei sulla pagina 1di 6

PROPOSAL OF PROJECT

MINI STEAM CAR

BFF 2233 Thermodynamics


Lecturer : Dr. Ahmad Redza Bin Ahmad Mokhtar

Faculty of Manufacturing Engineering


University Malaysia Pahang

Members

No Student ID Student Names Section


1 FB17014 Muhammad Syafi’i Bin Mas Duki 02
2 FB16062 Mohammed Faozi Mohammed Haidarah 02
3 FA18069 Muhammad Iylia' Bin Abdul Wahab 02
4 FA18101 Muhammad Afiq Miqhail Bin Johari 02
5 FA18104 Muhammad Yusuff Izzuddin Bin Roslan 02
TABLE OF CONTENT

NO. TITLE

1 INTRODUCTION

2 OBJECTIVE

3 SCOPE

4 PROJECT PLANNING

5 METHODOLOGY

6 REFERENCES
Introduction

The mini steam car project is an important part of the Thermodynamics course, student
will design and fabricate a lightweight and low-cost mini steam car having an elegance
appearance finish. The purpose of this paper is to provide some details about the mini steam car
project and to report results of its implementation in a thermodynamic courses. As students must
learn to make the best out of a given energy cycle by combining their knowledge of heat transfer,
thermal systems, and fundamental design. For the car to work, let alone accomplish the fastest
speed and long distance, various aspects of design beyond the scope of thermodynamics must be
taken into consideration: gear ratios, chassis design, material selection, and stresses acting on the
vehicle are amongst the crucial factors to consider for the successful completion of the car. Key
factors of these various projects are the level of technology and complexity, funding, and time
requirements. The micro steam car project does not require sophisticated instrumentation and
relies on basic engineering principles of energy conversion.

Objectives
 To apply the thermodynamics concepts by design and develop thermodynamics project.
 To explain the concepts of thermodynamics.
 To develop communication skills through team interaction to complete a design project
utilizing thermodynamics.
 To develop both creative and critical thinking skills

Scope
 Design and make a small steam car.
 Transfer the fluid to steam by heating.
 Use the steam and convert it to kinetic energy to make the car moving.
 Measure the heat, pressure and velocity.
 Solid work software will be used to design the parts.
Project Planning

GANTT CHART
MONTH FEBRUARY MARCH APRIL MAY
WEEK 3 4 5 6 7 8 9 10 11 12 13 14
CHAPTER 1
INTRODUCTION
Background of the
Project
Scope of Project

Objective

Gantt Chart

CHAPTER 2
METHODOLOG
Y
Procedure

Costing

Preparing materials

Development of
Steam Car
CHAPTER 3
RESULT &
DISCUSSION

Steam Car
Presentation
CHAPTER 4
CONCLUSIONS
Report Submission

Competition
Methodology

Bill Of Material

Material Quantity Cost (RM)


250ml drink tin 2 3
Pattern wheel 3 -
Rubber band 2 -
Epoxy Glue 1 -
Wooden axle 1 -
Candle 1 2
Nails 4 1
Small Tube 1 -
Total : RM6

Procedure of the Project

1. Prepare all materials and tools needed.


2. Poke holes and cut out the parts to the required specification.
3. Form the alignment jig, wheels and chassis.
4. Make the turbines and the boilers.
5. Balance the turbines.
6. Assemble all parts.
7. Test run.
Design

References

IEFX projects - Steam Car - Arduino Car


Retrieved online from: https://www.youtube.com/watch?v=Tmpo-JO1EQc

STEAM CAR: Experiment and Studies


Retrived online from: https://www.juliantrubin.com/encyclopedia/engineering/steam_car.html

Potrebbero piacerti anche