GasCalc® includes the following calculation modules
Module Application examples
(properties to be calculated) 1. Gas properties to ISO 6976 • Energy billing, conversion of reference Superior calorific value, Wobbe index, states (superior calorific value, normal normal density, molar mass, etc. density) • Monitoring / compliance with DVGW Code of Practice G260 (Wobbe index), for example biogas injection 2. Combustion • Design / control of combustion processes Air requirement, exhaust gas analysis, etc. 3. CO 2 emission factor • Determination of CO 2 output in accordance Calculated from gas analysis or based with DVGW Code of Practice G693 for on billing data emissions trading 4. Methane number • Avoiding engine knock in gas engines / Methane number to AVL method and packaged CHP simplified method • Monitoring / compliance with natural gas quality required at CNG fuelling stations 5. SGERG • Energy billing - conversion of volume at Thermal properties flowing conditions to volume at normal conditions (DVGW Code of Practice G486) (Compression factor, gas law deviation factor, density) to ISO 12213-3 6. AGA 8 • Energy billing in accordance with module 5 Thermal properties to ISO 12213-2, based on full analysis (DVGW Code of caloric properties (specific heat Practice G486, 2nd supplement) capacity, enthalpy, entropy, etc.) to • Design of heat exchangers, expansion / ISO 20765-1 compression processes 7. GERG 2004 reference equation • Calculation of data for liquefied natural gas Thermal and caloric properties over (LNG) processes entire fluid range (gas phase, liquid • Calculation of dew points, boiling points phase, two-phase boundary) • Calculation of data for extreme temperature and pressure conditions (storage) • Calculation of pure substance data
8. GERG Water • Monitoring / compliance with DVGW Code
Water dew point to ISO 18453 of Practice G260 9. Transport properties • Calculation of pressure loss in pipelines Dynamic viscosity, kinematic viscosity, • Fluid flow calculations (Reynolds number) heat conductivity, etc. 10. Compression • Design / optimisation of natural gas Isentropic / polytropic changes of state compressors based on AGA 8 equation • Compressor efficiency
11. Heater • Design and operation of heaters in pressure
Required temperature increase, heat reducing stations (regulators) output and gas consumption of natural gas-driven heaters to ISO 20765-1 12. Orifice calculation • Determination of normal volume for to ISO 5167 differential pressure meters
E.ON SE | Betrieb Essen – Brüsseler-Platz 1 – 45131 Essen