Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
WARNING: PUT THE SAFETY DEVICES AND THE WARNING NOTICES IN POSITION BEFORE
YOU START A TASK ON OR NEAR:
- THE FLIGHT CONTROLS
- THE FLIGHT CONTROL SURFACES
- THE LANDING GEAR AND THE RELATED DOORS
- COMPONENTS THAT MOVE.
MOVEMENT OF COMPONENTS CAN KILL OR CAUSE INJURY TO PERSONS AND/OR
CAN CAUSE DAMAGE TO THE EQUIPMENT.
WARNING: MAKE SURE THAT THE GROUND SAFETY-LOCKS ARE IN POSITION ON THE
LANDING GEAR. THIS WILL PREVENT UNWANTED MOVEMENT OF THE LANDING
GEAR, AND THUS POSSIBLE INJURY TO PERSONS AND DAMAGE TO THE
AIRCRAFT AND/OR EQUIPMENT.
1. Reason for the Job
To open the main landing gear (MLG) doors for access to equipment installed in zones 147 and
148.
2. Job Set-up Information
QT
REFERENCE DESIGNATION
Y
No specific AR SAFETY BARRIER(S)
No specific AR WARNING NOTICE(S)
B. Referenced Information
REFERENCE DESIGNATION
Ref. 32-00-00-481-002-A Installation of the Safety Devices on the Landing Gear
Doors
4. Procedure
** ON A/C FSN 001-002, 005-012
Ref. Fig. MLG Door Ground-Control-Handle
** ON A/C FSN 021-025, 028-029, 031-099, 101-199, 201-300, 401-450, 901-999
Ref. Fig. MLG Door Ground-Control-Handle
** ON A/C FSN ALL
SUBTASK 32-12-00-010-050-A
A. Open the Applicable MLG Door(s)
WARNING: MAKE SURE THAT THE TRAVEL RANGES OF THE LANDING GEAR ARE
CLEAR.
WARNING: INSTALL THE GROUND LOCK SLEEVE ON THE MLG DOOR ACTUATING
CYLINDER PISTON ROD IMMEDIATELY AFTER YOU OPEN THE MLG
DOOR. SUDDEN DOOR MOVEMENT CAN KILL YOU OR CAUSE INJURY.
(1) Open the access panel 195BB(196BB).
(2) Stand away from the travel range of the MLG door.
(3) Move the applicable MLG door control-handle to the OPEN position, as follows:
(a) Remove the safety pin.
(b) Push and hold in the pushbutton and move the handle down.
(c) Release the pushbutton to lock the handle in the OPEN position.
(d) Install the safety pin.
(4) If necessary, manually help the MLG door to open fully.
(5) Install the GROUND LOCK SLEEVE on the applicable MLG door actuating-cylinder Ref.
AMM TASK 32-00-00-481-002.
(6) If only one door is opened, put a WARNING NOTICE(S) on the control-handle of the
closed door. This notice must tell persons not to open the MLG door because persons
are near the MLG doors.
B
B
195BB
196BB
PUSH BUTTON
CONTROL HANDLE
SAFETY PIN
N_MM_321200_2_AAM0_01_00
B
B
195BB
196BB
PUSH BUTTON
CONTROL HANDLE
SAFETY PIN
N_MM_321200_2_ACM0_01_00