Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The
Guide
TO HELP CONTRIBUTE
TO THE DEL SOL GUIDE
Any comments / suggestions or information not contained in this text you think should be, please
E-Mail to: K_Schlagheck@msn.com
Index:
Section 1: General Information – Section 2: Model Information (Cont’d)–
Dimensions
Parameter Value
Length 157.3"
Width 66.7"
Height 49.4"
Ground Clearance 5.5"
Wheelbase 93.3"
Front/Rear Track 58.1" / 57.7"
Head / Leg Room 37.5" / 40.3"
Shoulder / Hip Room 52.9" / 49.3"
Cargo Volume 10.5 cu.ft. / 8.3 cu.ft. roof stowed
Passenger Volume 47.8 cu.ft.
Fuel Tank Capacity 11.9 gallons, 83 lbs.
Suspension A-Arm double wishbone
Drag Coefficient 0.378
Mechanical Cut-Away
(1) 1.6 liter 170-Horsepower DOHC (10) Body colored power remote
16-Valve Engine with Multi-Point control door mirror (door skin mount
Programmed fuel injection (PGM-FI) type)
and Variable Valve Timing (VTEC) (11) Front quarter window
(2) Front strut tower bar (12) Power rear window
(3) One piece turn signal and (13) Rear double wishbone
halogen headlight combo suspension
(4) Auxiliary light (14) Rear disk brake
(5) Round integral bumper x Automatic 4-speed
(6) Front double Wishbone transmission
suspension x Trans top (electromotive open
(7) Front large diameter ventilated roof)
disk brake x Door safety beam
(8) 195/55R15 83V tire x LED high mount brake light
(9) Bucket seat x Power trunk lid
Check Digit
Model Year
N: 1992
P: 1993
R: 1994
S: 1995
T: 1996
V: 1997
W: 1998
Factory Code
S: Suzuka Factory in Japan
Serial Number
Adriatic Blue Pearl Harvard Blue Pearl New Vogue Silver Metallic
B74P B63P NH583M
Exterior colors: Milano Red, Captiva Blue (Pearl), Granada Black (Pearl), Frost White.
Note: A special option was made available this year to introduce the del Sol in Samba Green with the optional Alloy
Wheels painted same color as the car along with special stripping
Exterior colors: Milano Red, Samba Green (Pearl), Granada Black (Pearl), Captiva Blue (Pearl).
Exterior colors: Paradise Blue Green (Pearl), Granada Black (Pearl), Milano Red, Frost White.
Exterior colors: Isle Green (Pearl), Milano Red, Granada Black (Pearl).
Interior colors: All Black panels with Gray panels only on roof panel and front window trim.
Exterior colors: Vogue Silver Metallic, Frost White, Milano Red, Granada Black (Pearl).
Exterior colors: Cypress Green (Pearl), Frost White, Milano Red, Granada Black (Pearl).
Exterior colors: Cypress Green (Pearl), Milano Red, Granada Black (Pearl).
Note: The options contained above are not known which years they became available, or whether which ones were
factory options, and which ones were offered by dealerships.
Above Left: 1993 Si SOHC VTEC Model Stock Engine (no A/C)
Above Right: (1994-1997) SOHC VTEC Stock Model engine
Exterior colors: Milano red, Flint black metallic, Vogue Silver Metallic, Captiva blue (pearl), Samba Green (pearl)
interior colors: All Black with upper Gray panels.
Interior Colors: All black panels with grey panels only on roof and front window trim
Exterior colors: Milano red, Frost white, New vogue silver metallic, Rhinoceros breath green (pearl)
Above Left: A close up of the Two Way Paradise decal which appeared only on the JDM CRX del Sol Limited and
Limited S models.
Above Right: A shot of the factory painted black targa roof which only the JDM CRX del Sol Limited offered.
Exterior colors: Milano red, Granada black (pearl), Vogue silver metallic, Cypress green (pearl)
Above Left: The exterior view of the CRX del Sol Motegi
Above Right: The interior view of the CRX del Sol Motegi
Engine Type/ Horsepower Torque (Ft- Compression OBD Donor Vehicles Origin
Code Displacement (Hp net) lb) Ratio 0/I/II
90’ – 91’ Civic SiR
90’ – 91’ Civic SiRII
88’ – 91’ Civic SiR
Hatchback
OBD0 90’ - 91’ Integra Xsi
90’ – 91’ Integra Rsi
88’ – 91’ Civic Vti
88’ – 91’ CRX 1.6i
88’ – 91’ CRX SiR
92’ – 93’ Integra Xsi
92’ – 93’ Integra Rsi
DOHC
B16A 1595cc 170 @ 7800 117 @ 7300 10:4:1 92’ – 95’ CRX Del JDM
VTEC Sol SiR
92’ – 95’ Civic SiR
92’ – 95’ Civic Ferio
OBDI Si
92’ – 95’ Civic Ferio
SiII
92’ – 95’ Civic Ferio
SiR
92’ – 95’ Civic Ferio
RTSi 4WD
96’ - 97’ Del Sol SiR
OBDII 96’ – 00’ Civic SiR
96’ – 00’ Civic SiRII
96’ – 97’
DOHC OBDI
Del Sol VTEC
B16A2 1595cc 160 @ 7600 111 @ 7000 10:2:1 USDM
VTEC 99’ – 00’
OBDII
Civic Si
94’ – 95’ Del Sol
EDM
VTi
DOHC OBDI
B16A3 1595cc 160 @ 7600 111 @ 7000 10:2:1 94’ – 95’ Del Sol
USDM
VTEC VTEC
96’ – 97’ Del Sol
OBDII EDM
VTi
DOHC
98’ – 00’ Civic Type
B16B 1595cc 185 @ 8200 118 @ 7500 10:8:1 OBDII JDM
R
VTEC
DOHC
92’ – 93’ Integra
B17A1 1678cc 160 @ 7600 117 @ 7000 9:7:1 OBDI USDM
GSR
VTEC
Manuals
USDM Helms Manual scans
(door glass / weather stripping, interior trim, center consoles, rear bins, dashboard, seats, carpet, front bumper, roof rail
trim)
Mudflap Installation
Spoiler Installation
Service Bulletins
Issue resolutions straight from Honda
AII 18040
INSTALLATION POWER ANTENNA 1997 DEL SOL Issue Date
INSTRUCTIONS P/N 08B41-SR2-100
AUG 1996
INSTALLATION
Before You Begin:
S Write down the customer’s radio station
presets; the radio memory will be erased when
you disconnect the battery.
S If the radio has a coded theft protection circuit,
be sure you have the anti-theft code number
before you disconnect the battery.
SELF-TAPPING
SCREW (Reuse.)
6 Cushion tapes
3 Wire ties
3. Inside the vehicle, remove the rear bulkhead 6. Remove the front console:
cover (nine clips, pull gently). M/T only: two self-tapping screws, shift knob,
4. Remove the rear storage compartment (six two clips.
self-tapping screws, six clips).
SELF-TAPPING SCREW Pull gently.
REAR
BULKHEAD
COVER
CLIP
SHIFT KNOB
FRONT CONSOLE
REAR STORAGE
COMPARTMENT
SELF-TAPPING
SCREW (Reuse.)
RIGHT
7. Remove the radio from the radio bracket. Refer
SIDE to the Radio Installation Instructions furnished
UPPER
LINING in the binder.
RIGHT
SIDE
LOWER
LINING
EXPANSION CLIP
(Reuse.)
SELF-TAPPING
SCREWS
(Reuse.) : Shows retaining clip.
Routing the Power Antenna Harness 11. Unplug the 16-pin connector from the rear of
the radio, and connect the 16-pin connector of
8. Route the power antenna harness (the end the power antenna harness in between.
with the ground terminal and 1-pin connector
with fuse) over the steering shaft. Route the 12. Reinstall the radio.
other end to the right (passenger’s side) of the 16-PIN CONNECTOR OF
vehicle under the center frame. VEHICLE HARNESS
NO. 5 CONNECTOR
15. Remove the tape to free the antenna lead.
WIRE TIES
FUSE BOX
ANTENNA
HOOD LEAD
OPENER
LEVER
BOLT 1-PIN CONNECTOR
CENTER
FRAME
16. Remove the antenna cover (two screws). 19. While pushing up on the power antenna,
tighten the nut on the stud; then tighten the
SCREWS antenna nut using the special tool.
ANTENNA NUT WRENCH
(T/N 07JAA-001000C)
GUIDE BASE
COVER
POWER ANTENNA
MOUNTING HOLE
ANTENNA
NUT
17. Remove the antenna nut and the guide base
from the power antenna. Connect the antenna
lead from the radio and the 3-pin connector of
the power antenna harness to the power FRAME
antenna. HOLE
NUT ON
POWER
ANTENNA NUT ANTENNA
BRACKET
GUIDE BASE 20. Secure the power antenna harness with three
cushion tapes in the areas shown.
POWER ANTENNA
HARNESS
POWER
ANTENNA
HARNESS
CUSHION
ANTENNA LEAD TAPES
Works Cited
Websites
Honda Motor Company of Japan……………..(http://www.honda.co.jp/)
Temple of Vtec Asia………………………….. (http://asia.vtec.net/)
Team Sol International ………………………...(http://www.teamdelsol.com/)
Team Sol Washington………………………….(http://www.teamdelsolwa.com/)
Club Si…………………………………………...(http://www.clubsi.com/)
NHTSA…………………………………………...(http://www.nhtsa.gov/)
Hondavision……………………………………...(http://www.hondavision.com/)
DelSolUK…………………………………………(http://www.delsoluk.com)
Sol Society………………………………………(http://www.solsociety.com)
CRX PT…………………………………………..(http://crxpt.com)
Books
1995 Honda Del Sol factory service manual
1995 Honda Del Sol factory electrical troubleshooting manual
How to Build Honda Horsepower (Richard Holdener)
Honda Engine Swaps (Aaron Bonk)
High Performance Handling Handbook (Don Alexander)
Sport Compact Car Engine & Driveline Handbook (from the editors of SCC)
High Performance Honda Builder's Handbook Vol.1 (Joe Pettitt)
High Performance Honda Builder's Handbook Vol.2 (Joe Pettitt)
Honda / Acura Engine Performance (Mike Kojima)
Honda & Acura Performance Handbook (Mike Ancas)
Magazines
MotorTrend 11/94
TV Shows
Motorweek