Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
MIX Putty
Water Resistant premixed cement based skim coat for interior conditions
1. PRODUCT
E.MIX PUTTY is a specially blended premixed powder for thin and final coat plaster finish on
wall and ceiling, or on plastering surface. It is a water-resistant plaster which can be used in dry
and/or wet interior conditions. It is suitable for hand application on concrete, lightweight
concrete, blockwork and rendered surfaces but not on painted surfaces. The surface can be
further polished by ultra-fine sand paper to obtain an extra smooth surface.
1.1 Uses
Formulated to comply with European Norm, British Standard and Chinese Standard
Single component: fixed mixing proportion, ensure the quality of work
Highly workable
Mould resistance, water resistance and alkaline resistance
Suitable as a skim coat to receive paint
Extra smooth finishing after polish
Compatible to cementitious products
2. TECHNICAL DATA
Colour White
Thickness 0.5 – 2 mm
2
Coverage Approx. 1.0 kg/m /mm
2
Approx. 1.0 kg/m for 1 mm thickness
Consumption 2
Approx. 25 m / 25 kg bag for 1 mm thickness
P1/3
3. PHYSICAL PROPERTIES
Coutinho Ring,
Shrinkage Nil
HKHA MTS (2002/2004) Spec. Part D, Cl. 2.1.6)
Resistance to
Water resistance JG/T 3049 : 1998
water immersion
Water retentivity BS 4551 : 2005 > 99%
Resistance to
Alkaline resistance JG/T 3049 : 1998 alkaline
immersion
Unless specified, all technical data are average values and refer to 28 days curing time.
Above physical data are taken on laboratory tests. In situ material performance may vary
according to environmental & workmanship conditions beyond manufacturer control.
4. PROCEDURE
Substrate must be free from grease, mould oil, rust, rusty metal, wood peels, paints, plastics,
loose particles, contamination on any traces of foreign materials affecting the adhesion of
E.MIX PUTTY.
Substrate is to be moistened overnight and also at the time before the installation.
For wooden board or other highly water absorbent substrates, substrate surface must be
primed with E.MIX MOISTURE SEALER.
P2/3
4.2 Mixing and Installation
Mix the dry mix powder with an electric mixer of 25 kg/bag with approximately 37% – 39%
(9.25 – 9.75 liter) of water.
Smooth the surface with trowel to remove the air bubbles on the surface of the E.MIX PUTTY.
When there are still bubbles on the surface, trowel the surface again.
The E.MIX PUTTY surface should be waited for at least 3 days to reduce the alkalinity.
4.3 Curing
Natural air curing for E.MIX PUTTY is enough. Water mist is not required for interior application.
However, water mist is requested under extremely hot or dry condition. To obtain high early
strength, water mist curing is recommended on the first and second day.
E.MIX PUTTY is delivered in 25 kg bag. Storage life is 12 months if the product is kept in a dry
place.
Recommend to wear NIOSH approved or equivalent particulate face mask when mixing the
material.
Materials may cause irritation to eyes and skin. In case of contact with eyes, rinse immediately
with plenty of water and seek medical assistance. After contact with skin, wash immediately
with plenty of soap and water.
*Note: Because it is not possible to give specific instructions for various site conditions or to control the applications, the information on this
Technical Data Sheet is for general guidance only and we reserve the right to modify the information detailed in this Technical Data Sheet.
P3/3