Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
items
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 1/9
2/16/2019 Horizon Air Q400 pre-training memory items Flashcards | Quizlet
Definition of icing Taxi and takeoff to the point of lift off: OAT is 10°C
conditions on the or below with precip or fog (vis < 1SM), or presence
ground of snow, ice, slush, standing water on surface.
Definition of icing After lift off until landing: SAT is 5° C or below and
conditions in flight vis moisture is present.
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 2/9
2/16/2019 Horizon Air Q400 pre-training memory items Flashcards | Quizlet
Max wind for holding Wind must be within 45° of the nose when greater
brakes and setting than 8 knots
takeoff power for
takeoff
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 3/9
2/16/2019 Horizon Air Q400 pre-training memory items Flashcards | Quizlet
What limit on flight The airplane shall not be operated farther than one
time is there unless hour flying time from a suitable airport for landing.
forward and aft
baggage
compartments are
empty?
Can you start the APU No, it would disrupt a steady electrical state.
during any refueling?
Max OAT for APU ops +50° C or +35° C ISA, whichever is lower
When must APU be Whenever it is shut down in OAT is below -35° C and
preheated? the APU has been shut down for more than one
hour.
When must the APU Whenever the aircraft is being deiced or anti-iced.
bleed air be off during
APU ops?
When must the Other than CAT III, at or above 200' AFE.
autopilot be
disengaged during
coupled approaches?
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 5/9
2/16/2019 Horizon Air Q400 pre-training memory items Flashcards | Quizlet
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 7/9
2/16/2019 Horizon Air Q400 pre-training memory items Flashcards | Quizlet
"TOO LOW - GEAR!" Airspeed below 190 KIAS, within 500' AGL, landing
gear up. Accomplish missed approach.
"TOO LOW - FLAPS!" Terrain within 250', gear down, flaps not in selected
EGPWS landing configuration. Accomplish missed
approach.
"SINK RATE, SINK Excessive descent rate below 2,500' AGL. Reduce
RATE!" descent rate, usually 1,000 FPM will work. If
uncorrected, may result in "PULL UP!"
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 8/9
2/16/2019 Horizon Air Q400 pre-training memory items Flashcards | Quizlet
https://quizlet.com/259200084/horizon-air-q400-pre-training-memory-items-flash-cards/ 9/9