Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Product Description
and other Huawei trademarks are trademarks of Huawei Technologies Co., Ltd.
All other trademarks and trade names mentioned in this document are the property of their respective
holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and
the customer. All or part of the products, services and features described in this document may not be
within the purchase scope or the usage scope. Unless otherwise specified in the contract, all statements,
information, and recommendations in this document are provided "AS IS" without warranties, guarantees or
representations of any kind, either express or implied.
The information in this document is subject to change without notice. Every effort has been made in the
preparation of this document to ensure accuracy of the contents, but all statements, information, and
recommendations in this document do not constitute a warranty of any kind, express or implied.
Website: http://www.huawei.com
Email: support@huawei.com
Contents
1 Introduction.................................................................................................................................... 1
1.1 Positioning ....................................................................................................................................................... 1
1.2 Benefits ............................................................................................................................................................ 2
2 Architecture .................................................................................................................................... 3
2.1 Logic Structure and Function ........................................................................................................................... 3
2.2 Appearance and Interface ................................................................................................................................. 4
1 Introduction
1.1 Positioning
The rapid development of mobile communication technology brings sharp growth in the
number of mobile phone users. This growth creates increasingly high requirements for
network quality. Besides enhancing network coverage, operators also need to increase
network capacity to meet rapid increases in traffic volume.
In many hot spots, insufficient of network capacity and the existence of blind spots greatly
affect user experience. To solve these problems, operators urgently need an accurate and
low-cost coverage solution with flexible site deployment.
Following the philosophy of continuous innovation based on customers’ requirements,
Huawei unveils the industry-leading WCDMA mini base station BTS3902E. Characterized by
its small size, light weight, plug-and-play functionality, auto-configuration, and no
requirements for shelter or equipment room, the BTS3902E is flexible in site acquisition and
deployment, making it a quick and flexible site solution for operators.
The BTS3902E is a bi-carrier product. Figure 1-1 shows the unit.
1.2 Benefits
Compact Structure for Quick Network Construction
With a highly integrated design, the BTS3902 is small, light, and requires less spare parts,
making it easy to install and maintain. The BTS3902E features strong environment
adaptability and has no need for an equipment room. It can be flexibly mounted on a wall or a
pole. The BTS3902E supports both integrated and separated antennas.
2 Architecture
NOTE
*: Port ETH and port OPT1 cannot be used at the same time.
5 Technical Specifications
5.1 RF Specifications
Table 5-1 RF Specifications
Item Specifications
Frequency Band Frequency Band Receive Frequency Transmit Frequency
Band (MHz) Band (MHz)
1900 MHz 1850 to 1910 1930 to 1990
2100 MHz 1920 to 1980 2110 to 2170
AWS 1710 to 1755 2110 to 2155
Receiver sensitivity Frequency Band Receive Diversity Receive Diversity
Sensitivity for Single Sensitivity for
Antenna (dBm) Double Antenna
(dBm)
1900 MHz/2100 -123.0* -125.8*
MHz/AWS
NOTE
*As recommended in 3GPP TS25.104, receiver sensitivity is measured at the
antenna connector on the condition that the data rate over the channel
reaches 12.2 kbit/s and the Bit Error Rate (BER) does not exceed 0.001.
Item Specifications
VSWR <2
Transmission ports FE/GE electrical port, FE/GE optical port
5.2 Capacity
Table 5-2 Capacity
Item Specifications
Capacity Two cells
Uplink: 192 CEs
Downlink: 192 CEs
The maximum output power equals the maximum output power of the power amplifier minus the
internal loss. The maximum output power is measured at the antenna connector in the RF module.
BTS3902E supports configuration of power amplifiers with different power.
The typical power consumption is measured with the equipment 40% loaded at a temperature of
25°C.
The maximum power consumption is measured with the equipment 100% loaded at a temperature of
25°C.
5.4 Clock
Table 5-5 Clock
Item Specifications
Clock IP clock (IEEE 1588V2) is synchronous with the Ethernet clock.
synchronization Precision: 0.05 ppm
Item Specification
Dimensions 300 mm x 270 mm x 120 mm (without the antennas and case)
(height x 300 mm x 277 mm x 145 mm (with the antennas and case)
width x
depth)
Weight 11 Kg (without the antennas and the case)
13 Kg (with the antennas and the case)
Input Input 110V/220V AC, 90/180V AC to 135/290V AC
voltage
Output POE Port: -54V, 30W
MTBF 308 462 hours
MTTR 1 hours
Availability 0. 999996
Item Specification
Temperature -40°C to +45°C (with solar radiation)
-40°C to +50°C (without solar radiation)
Item Specification
Transportatio ETSI EN300019-1-2 V2.1.4 (2003-04) Class 2.3 "Public transportation".
n
environment
Anti-seismic IEC 60068-2-57 (1999-11) Environmental Testing – Part 2-57: Tests –
performance Test Ff: Vibration – Time-history method.
YD5083-99: Interim Provisions for Test of Anti-seismic Performance of
Telecommunications Equipment.
Item Specifications
EMC The BTS3902E can meet the demand of electromagnetic
compatibility and is in accordance with the following
standards:
CISPR 22
EN 55022
EN 301 489-17
EN 301 489-23
CISPR 24
IEC 61000-4-2
IEC 61000-4-3
IEC 61000-4-4
IEC 61000-4-5
IEC 61000-4-6
GB 9254
ETSI 301 489-1
VCCI V-3
GB 9254-2008
3GPP R99, R4, R5, R6, R7, R8, R9,and R10
Environmental protection RoHS
standard
Lightning protection IEC61000-4-5, IEC 61312-1, YD 5098
standard
Protection standard YD 5098, YD 5068-98, IEC 61000-4-5
Item Specifications
Security standard UL60950-1, IEC60950-1, EN60950-1, AS/NZS60950-1,
UL60950-22, IEC60950-22, EN60950-22,
AS/NZS60950-22
Environmental standard IEC 68-2-1, IEC 68-2-2, IEC60068-2-2, ETSI
EN300019-1-1, ETSI EN300019-1-2, ETSI EN300019-1-4
Protection level IP65
C
CAPEX Capital Expenditure
CE Channel Element
D
DHCP Dynamic Host Configuration Protocol
E
EIRP Equivalent Isotropically Radiated Power
EMC Electromagnetic Compatibility
F
FE Fast Ethernet
G
GE Gigabit Ethernet
GGSN Gateway GPRS Support Node
H
HSDPA High Speed Downlink Packet Access
HSUPA High Speed Uplink Packet Access
HSPA+ High speed packet access plus
HPBW Half-power beamwidth
I
IEEE Institute Of Electrical And Electronics
Engineers
IP Internet Protocol
L
LMT Local Maintenance Terminal
M
MAC Media Access Control
MGW Media Gateway
MIMO Multiple-input multiple-output
MSC Mobile Switching Center
MTBF mean time between failures
O
OFDM Orthogonal Frequency Division Multiplexing
P
PA Power Amplifier
R
RNC Radio Network Controller
RoHS Restriction of the use of certain hazardous
substances
S
SGSN Serving GPRS Support Node
T
TRX Transceiver
U
UE User Equipment
W
WCDMA Wideband Code Division Multiple Access