Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Locate the four screw holes on the base plate of Locate the power, Ethernet and Emergency
the robot (see circles below). Mount P-Rob stop connectors on the back panel of the robot.
using four M6 or M8 (recommended) screws. E-Stop connector matches a keyed plug, which
may require rotating the plug until the key lines
up and the plug can be pushed in. Make sure
the E-Stop is not pressed and ready to be used.
By default, P-Rob comes with a static IP address Press the button located at the front of the base
of 192.168.80.203 within the netmask of P-Rob to start-up the embedded PC (and
255.255.255.0. If you want to change these myP, which is preinstalled on this PC). During the
settings, follow the instructions in the myP User start-up process, the button will show a blue
Manual, but we suggest for you to try to blinking light. As soon as the light stops blinking
establish a connection first to make sure it and stays blue, myP is ready to be used.
works.
F&P Robotics AG
Rohrstrasse 36
8152 Glattbrugg
Switzerland