Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
0 Introduction
M/s. National Thermal Power Corporation ltd., FGUTPP has awarded a Work contract to
Quality Network Private Ltd., Chennai to carry out Eddy Current Testing of Steam Turbine
condenser tubes at Unit # 02, 210 MW Turbine during annual overhaul. The same was carried
out between 06th NOVEMBER 2005 - 09th NOVEMBER 2005 . This is the final report on the
findings.
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
in Eddy current and interruption in the flow of Eddy current due to physical condition of the
condenser tubes and changes in material properties.
Specimens to be tested were tubes of the Steam Turbine Condensers. Condensers consisted of
a few thousands of tubes of diameter 25.4 mm and thickness 1.2 mm and made of Cupro
– Nickel ( 90 : 10 ) material. These were supported by a number of Internal Baffle plates in
between two end sheets. These tubes may have undergone deterioration due to service
conditions and by water chemistry, temperature, flow, and other plant operational parameters.
The defects that cause failure of condenser tubes are pitting, dents, general wall thinning,
localized wall loss, cracks and deposition. Some of these defects are pronounced near tube
supports plates. Early detection and characterization of defects will prevent forced outages of the
condenser tubes and helps to plan proper corrective action.
3.1 TestSetup
The diagram shows the test set up of MFEC- 04 system, which consists of the following
components:
2. MFEC- 04 Hardware
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
Following are some of the salient features of the equipment.
Four simultaneous frequencies and four independent channels were operated as follows:
Channel 1 - is operated in the differential mode to detect pits.
Channel 2 - is the mixer channel to cancel the tube sheet signal.
Channel 3 - is used in absolute mode to detect thickness variations.
Channel 4 - is a flaw discrimination channel. This channel is used to differentiate
4 . 0 Re f e r e n c e S t a n d a r d Fo l l o w e d
1 . A S M E B o i l e r a n d P re s s u r e V e s s e l C o d e - S e c t i o n – V , A r t i c l e 0 8 - E d d y C u r r e n t
E x a m i n at i o n o f t h e tu b u la r pr o du c t s .
2 . A S M E B o i l e r a n d P re s s u r e V e s s e l C o d e - S e c t i o n - V , A r t i c l e 0 8 - A p p e n d i x - I E d d y
c u r r e n t E x a mi n a t i on m e t h o d f o r in st a l l e d N o n - F e r ro m a gn e t i c H e at E x c h a n g er Tu
bi ng.
3 . A S T M D e s i g n at i on E 69 0 – 85 : St a n d a rd p r a c t i c e f o r I n – s it u E l e c t r o ma g n e t i c
(E d d y – Cu rr e n t ) E x ami n a ti o n o f N o n m a gn et ic H e at E x c h a n ge r T u be s.
4 . A S T M D e s i g n at i o n E 2 6 8 – 8 4a : S t an d a r d D e f i n it i o n s of Te rm s R e l a t i n g to
E l e c t r o m a gn e t i c Te st i n g
4 . 1 St an d ar d Ca l i br at io n T u be
A standard tube with identical composition of Cupro - Nickel material having same dimensions
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
of condenser tubes of OD of 25.4 mm and nominal wall thickness of 1.2mm. The standard tube with
artificial defects were fabricated as follows to meet the requirements of Standard specification for
Eddy Current Examination of Tubular Products – ASME Boiler and Pressure Vessel Code - Section – V,
Article 08.
Artificial Defects for Calibration:
Defect a: 1.6mm wide ,20%of WT( 0.2 mm depth ) external circumferential notch.
Defect b: 1.6mm wide ,20%of WT( 0.2 mm depth ) internal circumferential notch.
Defect c: 2mm dia,drilled upto 100%( 01mm depth )of WT ,single wall
Defect d: 2.8mm dia,drilled upto 80%( 0.8mm depth )of WT ,single wall
Defect e: 2.8mm dia,drilled upto 60%( 0.6mm depth )of WT ,single wall
Defect f: 4.8mm dia,drilled upto 40%( 0.4 mm depth )of WT ,single wall
Defect g:4.8mm dia,drilled upto 20%( 0.2 mm depth )of WT, Four holes 900 apart, circumfer.
Note: WT= wall thickness.
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
4.4 Equipment Calibration(At Field):
The Eddy current parameters that were set at laboratory for calibration were recalled at site and
calibration was verified before starting the testing. After ensuring the optimization of the
parameters, the testing was carried out. Signals from artificial defects, which were introduced in
the standard tube and set up parameters were stored for reference.
After balancing, calibration was verified at suitable intervals to maintain same conditions. As per
the customer's requirement about 4148 tubes (total) were tested from all four Sections of the
Unit # 02 condenser. The eddy current data obtained from the tubes was recorded. The details of
the tested tubes are given in Tables below. The eddy current signals obtained from some of the
tubes from different sections are given in Figures . These are typical results based on the extent of
damage of the tubes.
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
COLOUR CODES & SYMBOLS USED FOR TUBE SHEET MAPPING
DESCRIPTION SYMBOL
NDD
10-19.9%
20-29.9%
30-39.9%
40-49.9%
50-59.9%
60-69.9%
70-79.9%
80-89.9%
RSTR-PARTIAL
OBS-NO DATA
PLUGGED
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
TUBE TEST SUMMARY
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1 1 NDD 26 1 NDD
1 26
2 1 2 NDD 27 1 27 NDD
3 1 3 NDD 28 1 28 NDD
4 1 4 NDD 29 1 29 NDD
5 1 5 NDD 30 1 30 NDD
6 1 6 NDD 31 1 31 NDD
7 1 7 NDD 32 1 32 NDD
8 1 8 NDD 33 1 33 NDD
9 1 9 NDD 34 1 34 NDD
10 1 10 NDD 35 1 35 NDD
11 1 11 NDD 36 1 36 NDD
12 1 12 NDD 37 1 37 NDD
13 1 13 NDD 38 1 38 NDD
14 1 14 NDD 39 1 39 NDD
15 1 15 NDD 40 1 40 NDD
16 1 16 NDD 41 1 41 NDD
17 1 17 NDD 42 1 42 NDD
18 1 18 NDD 43 2 1 NDD
19 1 19 NDD 44 2 2 NDD
20 1 20 NDD 45 2 3 NDD
21 1 21 NDD 46 2 4 NDD
22 1 22 NDD 47 2 5 NDD
23 1 23 NDD 48 2 6 NDD
24 1 24 NDD 49 2 7 NDD
25 1 25 NDD 50 2 8 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
9 NDD 76 2 34 NDD
51 2
2 10 NDD 77 2 35 NDD
52
2 11 NDD 78 2 36 NDD
53
2 12 NDD 79 2 37 NDD
54
2 13 NDD 80 2 38 NDD
55
2 14 NDD 81 2 39 NDD
56
2 15 NDD 82 2 40 NDD
57
2 16 NDD 83 2 41 NDD
58
2 17 NDD 84 2 42 NDD
59
2 18 NDD 85 3 1 NDD
60
2 19 NDD 86 3 2 NDD
61
2 20 NDD 87 3 3 NDD
62
2 21 NDD 88 3 4 NDD
63
2 22 NDD 89 3 5 NDD
64
2 23 NDD 90 3 6 NDD
65
2 24 NDD 91 3 7 NDD
66
2 25 NDD 92 3 8 NDD
67
2 NDD 93 3 9 NDD
68 26
69 2 27 NDD 94 3 10 NDD
70 2 28 NDD 95 3 11 NDD
71 2 29 NDD 96 3 NDD
12
72 2 30 NDD 97 3 13 NDD
73 2 31 NDD 98 3 14 NDD
74 2 32 NDD 99 3 15 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
101 3 17 NDD 126 3 42 NDD
102 3 18 NDD 127 3 43 NDD
103 3 19 NDD 128 3 44 NDD
104 3 20 NDD 129 3 45 NDD
105 3 21 NDD 130 3 46 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
151 4 21 NDD 176 5 NDD
1
152 4 22 NDD 177 5 2 NDD
153 4 23 NDD 178 5 3 NDD
154 4 24 NDD 179 5 4 NDD
155 4 25 NDD 180 5 5 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
201 5 26 NDD 226 6 5 NDD
202 5 27 NDD 227 6 6 NDD
203 5 28 NDD 228 6 7 NDD
204 5 29 NDD 229 6 8 NDD
205 5 30 NDD 230 6 9 NDD
206 5 31 NDD 231 6 10 NDD
207 5 32 NDD 232 6 11 NDD
208 5 33 NDD 233 6 12 NDD
209 5 34 NDD 234 6 13 NDD
210 5 35 NDD 235 6 14 NDD
211 5 36 NDD 236 6 15 NDD
212 5 37 NDD 237 6 16 NDD
213 5 38 NDD 238 6 17 NDD
214 5 39 NDD 239 6 18 NDD
215 5 40 NDD 240 6 19 NDD
216 5 41 NDD 241 6 20 NDD
217 5 42 NDD 242 6 21 NDD
218 5 43 NDD 243 6 22 NDD
219 5 44 NDD 244 6 23 NDD
220 5 45 NDD 245 6 24 NDD
221 5 46 NDD 246 6 25 NDD
222 6 NDD 247 6 26 NDD
1
223 6 2 NDD 248 6 27 NDD
224 6 3 NDD 249 6 28 NDD
225 6 4 NDD 250 6 29 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
251 6 30 NDD 276 7 10 NDD
252 6 31 NDD 277 7 11 NDD
253 6 32 NDD 278 7 12 NDD
254 6 33 NDD 279 7 13 NDD
255 6 34 NDD 280 7 14 NDD
256 6 35 NDD 281 7 15 NDD
257 6 36 NDD 282 7 16 NDD
258 6 37 NDD 283 7 17 NDD
259 6 38 NDD 284 7 18 NDD
260 6 39 NDD 285 7 19 NDD
261 6 40 NDD 286 7 20 NDD
262 6 41 NDD 287 7 21 NDD
263 6 42 NDD 288 7 22 NDD
264 6 43 NDD 289 7 23 NDD
265 6 44 NDD 290 7 24 NDD
266 6 45 NDD 291 7 25 NDD
267 7 1 NDD 292 7 26 NDD
268 7 2 NDD 293 7 27 NDD
269 7 3 NDD 294 7 28 NDD
270 7 4 NDD 295 7 29 NDD
271 7 5 NDD 296 7 30 NDD
272 7 6 NDD 297 7 31 NDD
273 7 7 NDD 298 7 32 NDD
274 7 8 NDD 299 7 33 NDD
275 7 9 NDD 300 7 34 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
301 7 35 NDD 326 8 14 NDD
302 7 36 NDD 327 8 15 NDD
303 7 37 NDD 328 8 16 NDD
304 7 38 NDD 329 8 17 NDD
305 7 39 NDD 330 8 18 NDD
306 7 40 NDD 331 8 19 NDD
307 7 41 NDD 332 8 20 NDD
308 7 42 NDD 333 8 21 NDD
309 7 43 NDD 334 8 22 NDD
310 7 44 NDD 335 8 23 NDD
311 7 45 NDD 336 8 24 NDD
312 7 46 NDD 337 8 25 NDD
313 8 1 NDD .338 8 26 NDD
314 8 2 NDD 339 8 27 NDD
315 8 3 NDD 340 8 28 NDD
316 8 4 NDD 341 8 29 NDD
317 8 5 NDD 342 8 30 NDD
318 8 6 NDD 343 8 31 NDD
319 8 7 NDD 344 8 32 NDD
320 8 8 NDD 345 8 33 NDD
321 8 9 NDD 346 8 34 NDD
322 8 10 NDD 347 8 35 NDD
323 8 11 NDD 348 8 36 NDD
324 8 12 NDD 349 8 37 NDD
325 8 13 NDD 350 8 38 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
351 8 39 NDD 376 9 14 NDD
352 8 40 NDD 377 9 15 NDD
353 8 41 NDD 378 9 16 NDD
354 8 42 NDD 379 9 17 NDD
355 8 43 NDD 380 9 18 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
401 9 39 NDD 426 10 18 NDD
402 9 40 NDD 427 10 19 NDD
403 9 41 NDD 428 10 20 NDD
404 9 42 NDD 429 10 21 NDD
405 9 43 NDD 430 10 22 NDD
406 9 44 NDD 431 10 23 NDD
407 9 45 NDD 432 10 24 NDD
408 9 46 NDD 433 10 25 NDD
409 10 1 NDD 434 10 26 NDD
410 10 2 NDD 435 10 27 NDD
411 10 3 NDD 436 10 28 NDD
412 10 4 NDD 437 10 29 NDD
413 10 5 NDD 438 10 30 NDD
414 10 6 NDD 439 10 31 NDD
415 10 7 NDD 440 10 32 NDD
416 10 8 NDD 441 10 33 NDD
417 10 9 NDD 442 10 34 NDD
418 10 10 NDD 443 10 35 NDD
419 10 11 NDD 444 10 36 NDD
420 10 12 NDD 445 10 37 NDD
421 10 13 NDD 446 10 38 NDD
422 10 14 NDD 447 10 39 NDD
423 10 15 NDD 448 10 40 NDD
424 10 16 NDD 449 10 41 NDD
425 10 17 NDD 450 10 42 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
451 10 43 NDD 476 11 23 NDD
452 10 44 NDD 477 11 24 NDD
453 10 45 NDD 478 11 25 NDD
454 11 1 NDD 479 11 26 NDD
455 11 2 NDD 480 11 27 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
501 12 2 NDD 526 12 27 NDD
502 12 3 NDD 527 12 28 NDD
503 12 4 NDD 528 12 29 NDD
504 12 5 NDD 529 12 30 NDD
505 12 6 NDD 530 12 31 NDD
506 12 7 NDD 531 12 32 NDD
507 12 8 NDD 532 12 33 NDD
508 12 9 NDD 533 12 34 NDD
509 12 10 NDD 534 12 35 NDD
510 12 11 NDD 535 12 36 NDD
511 12 12 NDD 536 12 37 NDD
512 12 13 NDD 537 12 38 NDD
513 12 14 NDD 538 12 39 NDD
514 12 15 NDD 539 12 40 NDD
515 12 16 NDD 540 12 41 NDD
516 12 17 NDD 541 12 42 NDD
517 12 18 NDD 542 12 43 NDD
518 12 19 NDD 543 12 44 NDD
519 12 20 NDD 544 12 45 NDD
520 12 21 NDD 545 13 1 NDD
521 12 22 NDD 546 13 2 NDD
522 12 23 NDD 547 13 3 NDD
523 12 24 NDD 548 13 4 NDD
524 12 25 NDD 549 13 5 NDD
525 12 26 NDD 550 13 6 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
551 13 6 NDD 576 13 31 NDD
552 13 7 NDD 577 13 32 NDD
553 13 8 NDD 578 13 33 NDD
554 13 9 NDD 579 13 34 NDD
555 13 10 NDD 580 13 35 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
601 14 10 NDD 626 14 35 NDD
602 14 11 NDD 627 14 36 NDD
603 14 12 NDD 628 14 37 NDD
604 14 13 NDD 629 14 38 NDD
605 14 14 NDD 630 14 39 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
651 15 15 NDD 676 15 40 NDD
652 15 16 NDD 677 15 41 NDD
653 15 17 NDD 678 15 42 NDD
654 15 18 NDD 679 15 43 NDD
655 15 19 NDD 680 15 44 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
701 16 21 NDD 726 17 1 NDD
702 16 22 NDD 727 17 2 NDD
703 16 23 NDD 728 17 3 NDD
704 16 24 NDD 729 17 4 NDD
705 16 25 NDD 730 17 5 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
751 17 26 NDD 776 18 7 NDD
752 17 27 NDD 777 18 8 NDD
753 17 28 NDD 778 18 9 NDD
754 17 29 NDD 779 18 10 NDD
755 17 30 NDD 780 18 11 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
18 36 NDD 19 16 NDD
801 826
18 37 NDD 19 17 NDD
802 827
18 38 NDD 19 18 NDD
803 828
18 39 NDD 19 19 NDD
804 829
18 40 NDD 19 20 NDD
805 830
18 41 NDD 19 21 NDD
806 831
18 42 NDD 19 22 NDD
807 832
18 43 NDD 19 23 NDD
808 833
18 44 NDD 19 24 NDD
809 834
18 45 NDD 19 25 NDD
810 835
19 1 NDD 19 26 NDD
811 836
19 2 NDD 19 27 NDD
812 837
19 3 NDD 19 28 NDD
813 838
19 4 NDD 19 29 NDD
814 839
19 5 NDD 19 30 NDD
815 840
19 6 NDD 19 31 NDD
816 841
19 7 NDD 19 32 NDD
817 842
19 8 NDD 19 33 NDD
818 843
19 9 NDD 19 34 NDD
819 844
19 10 NDD 19 35 NDD
820 845
19 11 NDD 19 36 NDD
821 846
19 12 NDD 19 37 NDD
822 847
19 13 NDD 19 38 NDD
823 848
19 14 NDD 19 39 NDD
824 849
19 15 NDD 19 40 NDD
825 850
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
901 19 41 NDD 926 20 22 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
951 21 2 NDD 976 21 27 NDD
952 21 3 NDD 977 21 28 NDD
953 21 4 NDD 978 21 29 NDD
954 21 5 NDD 979 21 30 NDD
955 21 6 NDD 980 21 31 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1001 22 8 NDD 1026 22 33 NDD
1002 22 9 NDD 1027 22 34 NDD
1003 22 10 NDD 1028 22 35 NDD
1004 22 11 NDD 1029 22 36 NDD
1005 22 12 NDD 1030 22 37 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1051 23 15 NDD 1076 23 40 NDD
1052 23 16 NDD 1077 23 41 NDD
1053 23 17 NDD 1078 23 42 NDD
1054 23 18 NDD 1079 23 43 NDD
1055 23 19 NDD 1080 23 44 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1101 24 21 NDD 1126 25 2 NDD
1102 24 22 NDD 1127 25 3 NDD
1103 24 23 NDD 1128 25 4 NDD
1104 24 24 NDD 1129 25 5 NDD
1105 24 25 NDD 1130 25 6 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1151 25 27 NDD 1176 26 8 NDD
1152 25 28 NDD 1177 26 9 NDD
1153 25 29 NDD 1178 26 10 NDD
1154 25 30 NDD 1179 26 11 NDD
1155 25 31 NDD 1180 26 12 NDD
1156 25 32 NDD 1181 25 13 NDD
1157 25 33 NDD 1182 25 14 NDD
1158 25 34 NDD 1183 25 15 NDD
1159 25 35 NDD 1184 25 16 NDD
1160 25 36 NDD 1185 25 17 NDD
1161 25 37 NDD 1186 25 18 NDD
1162 25 38 NDD 1187 26 19 NDD
1163 25 39 NDD 1188 26 20 NDD
1164 25 40 NDD 1189 26 21 NDD
1165 25 41 NDD 1190 26 22 NDD
1166 25 42 NDD 1191 26 23 NDD
1167 25 43 NDD 1192 26 24 NDD
1168 25 44 NDD 1193 26 25 NDD
1169 26 1 NDD 1194 26 26 NDD
1170 26 2 NDD 1195 26 27 NDD
1171 26 3 NDD 1196 26 28 NDD
1172 26 4 NDD 1197 26 29 NDD
1173 26 5 NDD 1198 26 30 NDD
1174 26 6 NDD 1199 26 31 NDD
1175 26 7 NDD 1200 26 32 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1201 26 33 1226 27 14 NDD
1202 26 34 NDD 1227 27 15 NDD
1203 26 35 NDD 1228 27 16 NDD
1204 26 36 NDD 1229 27 17 NDD
1205 26 37 NDD 1230 27 18 NDD
1206 26 38 NDD 1231 27 19 NDD
1207 26 39 NDD 1232 27 20 NDD
1208 26 40 NDD 1233 27 21 NDD
1209 26 41 NDD 1234 27 22 NDD
1210 26 42 NDD 1235 27 23 NDD
1211 26 43 NDD 1236 27 24 NDD
1212 26 44 NDD 1237 27 25 NDD
1213 27 1 NDD 1238 27 26 NDD
1214 27 2 NDD 1239 27 27 NDD
1215 27 3 NDD 1240 27 28 NDD
1216 27 4 NDD 1241 27 29 NDD
1217 27 5 NDD 1242 27 30 NDD
1218 27 6 NDD 1243 27 31 NDD
1219 27 7 NDD 1244 27 32 NDD
1220 27 8 NDD 1245 27 33 NDD
1221 27 9 NDD 1246 27 34 NDD
1222 27 10 NDD 1247 27 35 NDD
1223 27 11 NDD 1248 27 36 NDD
1224 27 12 NDD 1249 27 37 NDD
1225 27 13 NDD 1250 27 38 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1251 27 39 NDD 1276 28 20 NDD
1252 27 40 NDD 1277 28 21 NDD
1253 27 41 NDD 1278 28 22 NDD
1254 27 42 NDD 1279 28 23 NDD
1255 27 43 NDD 1280 28 24 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1301 29 1 NDD 1326 29 27 NDD
1302 29 2 NDD 1327 29 28 NDD
1303 29 3 NDD 1328 29 29 NDD
1304 29 4 NDD 1329 29 30 NDD
1305 29 5 NDD 1330 29 31 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1351 30 8 NDD 1376 30 34 NDD
1352 30 9 NDD 1377 30 35 NDD
1353 30 10 NDD 1378 30 36 NDD
1354 30 12 NDD 1379 30 37 NDD
1355 30 13 NDD 1380 30 38 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1401 31 14 NDD 1426 31 39 NDD
1402 31 15 NDD 1427 31 40 NDD
1403 31 16 NDD 1428 31 41 NDD
1404 31 17 NDD 1429 31 42 NDD
1405 31 18 NDD 1430 31 43 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1451 32 20 NDD 1476 33 2 NDD
1452 32 21 NDD 1477 33 3 NDD
1453 32 22 NDD 1478 33 4 NDD
1454 32 23 NDD 1479 33 5 NDD
1455 32 24 NDD 1480 33 6 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1501 33 27 NDD 1526 34 8 NDD
1502 33 28 NDD 1527 34 9 NDD
1503 33 29 NDD 1528 34 10 NDD
1504 33 30 NDD 1529 34 11 NDD
1505 33 31 NDD 1530 34 12 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1551 34 33 NDD 1576 35 15 NDD
1552 34 34 NDD 1577 35 16 NDD
1553 34 35 NDD 1578 35 17 NDD
1554 34 36 NDD 1579 35 18 NDD
1555 34 37 NDD 1580 35 19 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1601 35 40 NDD 1626 36 23 NDD
1602 35 41 NDD 1627 36 24 NDD
1603 35 42 NDD 1628 36 25 NDD
1604 36 1 NDD 1629 36 26 NDD
1605 36 2 NDD 1630 36 27 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1651 37 5 NDD 1676 37 30 NDD
1652 37 6 NDD 1677 37 31 NDD
1653 37 7 NDD 1678 37 32 NDD
1654 37 8 NDD 1679 37 33 NDD
1655 37 9 NDD 1680 37 34 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1701 38 13 NDD 1726 38 38 NDD
1702 38 14 NDD 1727 38 39 NDD
1703 38 15 NDD 1728 38 40 NDD
1704 38 16 NDD 1729 38 41 NDD
1705 38 17 NDD 1730 39 1 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1751 39 22 NDD 1776 40 5 NDD
1752 39 23 NDD 1777 40 6 NDD
1753 39 24 NDD 1778 40 7 NDD
1754 39 25 NDD 1779 40 8 NDD
1755 39 26 NDD 1780 40 9 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1801 40 30 NDD 1826 41 14 NDD
1802 40 31 NDD 1827 41 15 NDD
1803 40 33 NDD 1828 41 16 NDD
1804 40 33 NDD 1829 41 17 NDD
1805 40 34 NDD 1830 41 18 NDD
1806 40 35 NDD 1831 41 19 NDD
1807 40 36 NDD 1832 41 20 NDD
1808 40 37 NDD 1833 41 21 NDD
1809 40 38 NDD 1834 41 22 NDD
1810 40 39 NDD 1835 41 23 NDD
1811 40 40 NDD 1836 41 24 NDD
1812 40 41 NDD 1837 41 25 NDD
1813 41 1 NDD 1838 41 26 NDD
1814 41 2 NDD 1839 41 27 NDD
1815 41 3 NDD 1840 41 28 NDD
1816 41 4 NDD 1841 41 29 NDD
1817 41 5 NDD 1842 41 30 NDD
1818 41 6 NDD 1843 41 31 NDD
1819 41 7 NDD 1844 41 32 NDD
1820 41 8 NDD 1845 41 33 NDD
1821 41 9 NDD 1846 41 34 NDD
1822 41 10 NDD 1847 41 35 NDD
1823 41 11 NDD 1848 41 36 NDD
1824 41 12 NDD 1849 41 37 NDD
1825 41 13 NDD 1850 41 38 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. 1No. ROW Column WALL LOSS %
TYPE TYPE
1851 41 39 NDD 1876 42 24 NDD
1852 41 40 NDD 1877 42 25 NDD
1853 42 1 NDD 1878 42 26 NDD
1854 42 2 NDD 1879 42 27 NDD
1855 42 3 NDD 1880 42 28 NDD
1856 42 4 NDD 1881 42 29 NDD
1857 42 5 NDD 1882 42 30 NDD
1858 42 6 NDD 1883 42 31 NDD
1859 42 7 NDD 1884 42 33 NDD
1860 42 8 NDD 1885 42 34 NDD
1861 42 9 NDD 1886 42 35 NDD
1862 42 10 NDD 1887 42 36 NDD
1863 42 11 NDD 1888 42 37 NDD
1864 42 12 NDD 1889 42 38 NDD
1865 42 13 NDD 1890 42 39 NDD
1866 42 14 NDD 1891 42 40 NDD
1867 42 15 NDD 1892 42 41 NDD
1868 42 16 NDD 1893 43 1 NDD
1869 42 17 NDD 1894 43 2 NDD
1870 42 18 NDD 1895 43 3 NDD
1871 42 19 NDD 1896 43 4 NDD
1872 42 20 NDD 1897 43 5 NDD
1873 42 21 NDD 1898 43 6 NDD
1874 42 22 NDD 1899 43 7 NDD
1875 42 23 NDD 1900 43 8 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1901 43 9 NDD 1926 43 34 NDD
1902 43 10 NDD 1927 43 35 NDD
1903 43 11 NDD 1928 43 36 NDD
1904 43 12 NDD 1929 43 37 NDD
1905 43 13 NDD 1930 43 38 NDD
1906 43 14 NDD 1931 43 39 NDD
1907 43 15 NDD 1932 43 40 NDD
1908 43 16 NDD 1933 44 1 NDD
1909 43 17 NDD 1934 44 2 NDD
1910 43 18 NDD 1935 44 3 NDD
1911 43 19 NDD 1936 44 4 NDD
1912 43 20 NDD 1937 44 5 NDD
1913 43 21 NDD 1938 44 6 NDD
1914 43 22 NDD 1939 44 7 NDD
1915 43 23 NDD 1940 44 8 NDD
1916 43 24 NDD 1941 44 9 NDD
1917 43 25 NDD 1942 44 10 NDD
1918 43 26 NDD 1943 44 11 NDD
1919 43 27 NDD 1944 44 12 NDD
1920 43 28 NDD 1945 44 13 NDD
1921 43 29 NDD 1946 44 14 NDD
1922 43 30 NDD 1947 44 15 NDD
1923 43 31 NDD 1948 44 16 NDD
1924 43 32 NDD 1949 44 17 NDD
1925 43 33 NDD 1950 44 18 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
1951 44 19 NDD 1976 45 6 NDD
1952 44 20 NDD 1977 45 7 NDD
1953 44 21 NDD 1978 45 8 NDD
1954 44 22 NDD 1979 45 9 NDD
1955 44 23 NDD 1980 45 10 NDD
1956 44 24 NDD 1981 45 11 NDD
1957 44 25 NDD 1982 45 12 NDD
1958 44 26 NDD 1983 45 13 NDD
1959 44 27 NDD 1984 45 14 NDD
1960 44 28 NDD 1985 45 15 NDD
1961 44 29 NDD 1986 45 16 NDD
1962 44 30 NDD 1987 45 17 NDD
1963 44 31 NDD 1988 45 18 NDD
1964 44 33 NDD 1989 45 19 NDD
1965 44 34 NDD 1990 45 20 NDD
1966 44 35 NDD 1991 45 21 NDD
1967 44 36 NDD 1992 45 22 NDD
1968 44 37 NDD 1993 45 23 NDD
1969 44 38 NDD 1994 45 24 NDD
1970 44 39 NDD 1995 45 25 NDD
1971 45 1 NDD 1996 45 26 NDD
1972 45 2 NDD 1997 45 27 NDD
1973 45 3 NDD 1998 45 28 NDD
1974 45 4 NDD 1999 45 29 NDD
1975 45 5 NDD 2000 45 30 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2001 45 31 NDD 2026 46 17 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2051 47 2 NDD 2076 47 27 NDD
2052 47 3 NDD 2077 47 27 NDD
2053 47 4 NDD 2078 47 28 NDD
2054 47 5 NDD 2079 47 29 NDD
2055 47 6 NDD 2080 47 30 NDD
2056 47 7 NDD 2081 47 31 NDD
2057 47 8 NDD 2082 47 32 NDD
2058 47 9 NDD 2083 47 33 NDD
2059 47 10 NDD 2084 47 34 NDD
2060 47 11 NDD 2085 47 35 NDD
2061 47 12 NDD 2086 47 36 NDD
2062 47 13 NDD 2087 47 37 NDD
2063 47 14 NDD 2088 47 38 NDD
2064 47 15 NDD 2089 48 1 NDD
2065 47 16 NDD 2090 48 2 NDD
2066 47 17 NDD 2091 48 3 NDD
2067 47 18 NDD 2092 48 4 NDD
2068 47 19 NDD 2093 48 5 NDD
2069 47 20 NDD 2094 48 6 NDD
2070 47 21 NDD 2095 48 7 NDD
2071 47 22 NDD 2096 48 8 NDD
2072 47 23 NDD 2097 48 9 NDD
2073 47 24 NDD 2098 48 10 NDD
2074 47 25 NDD 2099 48 11 NDD
2075 47 26 NDD 2100 48 12 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2101 48 13 NDD 2126 49 1 NDD
2102 48 14 NDD 2127 49 2 NDD
2103 48 15 NDD 2128 49 3 NDD
2104 48 16 NDD 2129 49 4 NDD
2105 48 17 NDD 2130 49 5 NDD
2106 48 18 NDD 2131 49 6 NDD
2107 48 19 NDD 2132 49 7 NDD
2108 48 20 NDD 2133 49 8 NDD
2109 48 21 NDD 2134 49 9 NDD
2110 48 22 NDD 2135 49 10 NDD
2111 48 23 NDD 2136 49 11 NDD
2112 48 24 NDD 2137 49 12 NDD
2113 48 25 NDD 2138 49 13 NDD
2114 48 26 NDD 2139 49 14 NDD
2115 48 27 NDD 2140 49 15 NDD
2116 48 28 NDD 2141 49 16 NDD
2117 48 29 NDD 2142 49 17 NDD
2118 48 30 NDD 2143 49 18 NDD
2119 48 31 NDD 2144 49 19 NDD
2120 48 32 NDD 2145 49 20 NDD
2121 48 33 NDD 2146 49 21 NDD
2122 48 34 NDD 2147 49 22 NDD
2123 48 35 NDD 2148 49 22 NDD
2124 48 36 NDD 2149 49 23 NDD
2125 48 37 NDD 2150 49 24 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2151 49 25 NDD 2176 50 12 NDD
2152 49 26 NDD 2177 50 13 NDD
2153 49 27 NDD 2178 50 14 NDD
2154 49 28 NDD 2179 50 15 NDD
2155 49 29 NDD 2180 50 16 NDD
2156 49 30 NDD 2181 50 17 NDD
2157 49 31 NDD 2182 50 18 NDD
2158 49 32 NDD 2183 50 19 NDD
2159 49 33 NDD 2184 50 20 NDD
2160 49 34 NDD 2185 50 21 NDD
2161 49 35 NDD 2186 50 22 NDD
2162 49 36 NDD 2187 50 23 NDD
2163 49 37 NDD 2188 50 24 NDD
2164 49 38 NDD 2189 50 25 NDD
2165 50 1 NDD 2190 50 26 NDD
2166 50 2 NDD 2191 50 27 NDD
2167 50 3 NDD 2192 50 28 NDD
2168 50 4 NDD 2193 50 29 NDD
2169 50 5 NDD 2194 50 30 NDD
2170 50 6 NDD 2195 50 31 NDD
2171 50 7 NDD 2196 50 32 NDD
2172 50 8 NDD 2197 50 33 NDD
2173 50 9 NDD 2198 50 34 NDD
2174 50 10 NDD 2199 50 35 NDD
2175 50 11 NDD 2200 50 36 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2201 50 37 NDD 2226 51 25 NDD
2202 51 1 NDD 2227 51 26 NDD
2203 51 2 NDD 2228 51 27 NDD
2204 51 3 NDD 2229 51 28 NDD
2205 51 4 NDD 2230 51 29 NDD
2206 51 5 NDD 2231 51 30 NDD
2207 51 6 NDD 2232 51 31 NDD
2208 51 7 NDD 2233 51 32 NDD
2209 51 8 NDD 2234 51 33 NDD
2210 51 9 NDD 2235 51 34 NDD
2211 51 10 NDD 2236 51 35 NDD
2212 51 11 NDD 2237 51 36 NDD
2213 51 12 NDD 2238 52 1 NDD
2214 51 13 NDD 2239 52 2 NDD
2215 51 14 NDD 2240 52 3 NDD
2216 51 15 NDD 2241 52 4 NDD
2217 51 16 NDD 2242 52 5 NDD
2218 51 17 NDD 2243 52 6 NDD
2219 51 18 NDD 2244 52 7 NDD
2220 51 19 NDD 2245 52 8 NDD
2221 51 20 NDD 2246 52 9 NDD
2222 51 21 NDD 2247 52 10 NDD
2223 51 22 NDD 2248 52 11 NDD
2224 51 23 NDD 2249 52 12 NDD
2225 51 24 NDD 2250 52 13 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2251 52 14 NDD 2276 53 2 NDD
2252 52 15 NDD 2277 53 3 NDD
2253 52 16 NDD 2278 53 4 NDD
2254 52 17 NDD 2279 53 5 NDD
2255 52 18 NDD 2280 53 6 NDD
2256 52 19 NDD 2281 53 7 NDD
2257 52 20 NDD 2282 53 8 NDD
2258 52 21 NDD 2283 53 9 NDD
2259 52 22 NDD 2284 53 10 NDD
2260 52 23 NDD 2285 53 11 NDD
2261 52 24 NDD 2286 53 12 NDD
2262 52 25 NDD 2287 53 13 NDD
2263 52 26 NDD 2288 53 14 NDD
2264 52 27 NDD 2289 53 15 NDD
2265 52 28 NDD 2290 53 16 NDD
2266 52 29 NDD 2291 53 17 NDD
2267 52 30 NDD 2292 53 18 NDD
2268 52 31 NDD 2293 53 19 NDD
2269 52 32 NDD 2294 53 20 NDD
2270 52 33 NDD 2295 53 21 NDD
2271 52 34 NDD 2296 53 22 NDD
2272 52 35 NDD 2297 53 23 NDD
2273 52 36 NDD 2298 53 24 NDD
2274 52 37 NDD 2299 53 25 NDD
2275 53 1 NDD 2300 53 26 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
S. No. ROW Column WALL LOSS % FLAW TYPE S. No. ROW Column WALL LOSS % FLAW TYPE
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2351 55 7 NDD 2376 55 32 NDD
2352 55 8 NDD 2377 55 33 NDD
2353 55 9 NDD 2378 55 34 NDD
2354 55 10 NDD 2379 56 1 NDD
2355 55 11 NDD 2380 56 2 NDD
2356 55 12 NDD 2381 56 3 NDD
2357 55 13 NDD 2382 56 4 NDD
2358 55 14 NDD 2383 56 5 NDD
2359 55 15 NDD 2384 56 6 NDD
2360 55 16 NDD 2385 56 7 NDD
2361 55 17 NDD 2386 56 8 NDD
2362 55 18 NDD 2387 56 9 NDD
2363 55 19 NDD 2388 56 10 NDD
2364 55 20 NDD 2389 56 11 NDD
2365 55 21 NDD 2390 56 12 NDD
2366 55 22 NDD 2391 56 13 NDD
2367 55 23 NDD 2392 56 14 NDD
2368 55 24 NDD 2393 56 15 NDD
2369 55 25 NDD 2394 56 16 NDD
2370 55 26 NDD 2395 56 17 NDD
2371 55 27 NDD 2396 56 18 NDD
2372 55 28 NDD 2397 56 19 NDD
2373 55 29 NDD 2398 56 20 NDD
2374 55 30 NDD 2399 56 21 NDD
2375 55 31 NDD 2400 56 22 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
S. No. ROW Column WALL LOSS % FLAW S. No. ROW Column WALL LOSS % FLAW
TYPE TYPE
2401 56 23 NDD 2426 57 15 NDD
2402 56 24 NDD 2427 57 16 NDD
2403 56 25 NDD 2428 57 17 NDD
2404 56 26 NDD 2429 57 18 NDD
2405 56 27 NDD 2430 57 19 NDD
2406 56 28 NDD 2431 57 20 NDD
2407 56 29 NDD 2432 57 21 NDD
2408 56 30 NDD 2433 57 22 NDD
2409 56 31 NDD 2434 57 23 NDD
2410 56 32 NDD 2435 57 24 NDD
2411 56 33 NDD 2436 57 25 NDD
2412 57 1 NDD 2437 57 26 NDD
2413 57 2 NDD 2438 57 27 NDD
2414 57 3 NDD 2439 57 28 NDD
2415 57 4 NDD 2440 57 29 NDD
2416 57 5 NDD 2441 57 30 NDD
2417 57 6 NDD 2442 57 31 NDD
2418 57 7 NDD 2443 57 32 NDD
2419 57 8 NDD 2444 57 33 NDD
2420 57 9 NDD 2445 57 34 NDD
2421 57 10 NDD 2446 58 1 NDD
2422 57 11 NDD 2447 58 2 NDD
2423 57 12 NDD 2448 58 3 NDD
2424 57 13 NDD 2449 58 4 NDD
2425 57 14 NDD 2450 58 5 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2451 58 6 NDD 2476 58 31 NDD
2452 58 7 NDD 2477 58 32 NDD
2453 58 8 NDD 2478 58 33 NDD
2454 58 9 NDD 2479 59 1 NDD
2455 58 10 NDD 2480 59 2 NDD
2456 58 11 NDD 2481 59 3 NDD
2457 58 12 NDD 2482 59 4 NDD
2458 58 13 NDD 2483 59 5 NDD
2459 58 14 NDD 2484 59 6 NDD
2460 58 15 NDD 2485 59 7 NDD
2461 58 16 NDD 2486 59 8 NDD
2462 58 17 NDD 2487 59 9 NDD
2463 58 18 NDD 2488 59 10 NDD
2464 58 19 NDD 2489 59 11 NDD
2465 58 20 NDD 2490 59 12 NDD
2466 58 21 NDD 2491 59 13 NDD
2467 58 22 NDD 2492 59 14 NDD
2468 58 23 NDD 2493 59 15 NDD
2469 58 24 NDD 2494 59 16 NDD
2470 58 25 NDD 2495 59 17 NDD
2471 58 26 NDD 2496 59 18 NDD
2472 58 27 NDD 2497 59 19 NDD
2473 58 28 NDD 2498 59 20 NDD
2474 58 29 NDD 2499 59 21 NDD
2475 58 30 NDD 2500 59 22 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2501 59 23 NDD 2526 60 16 NDD
2502 59 24 NDD 2527 60 17 NDD
2503 59 25 NDD 2528 60 18 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2551 61 5 NDD 2576 61 30 NDD
2552 61 6 NDD 2577 62 1 NDD
2553 61 7 NDD 2578 62 2 NDD
2554 61 8 NDD 2579 62 3 NDD
2555 61 9 NDD 2580 62 4 NDD
2556 61 10 NDD 2581 62 5 NDD
2557 61 11 NDD 2582 62 6 NDD
2558 61 12 NDD 2583 62 7 NDD
2559 61 13 NDD 2584 62 8 NDD
2560 61 14 NDD 2585 62 9 NDD
2561 61 15 NDD 2586 62 10 NDD
2562 61 16 NDD 2587 62 11 NDD
2563 61 17 NDD 2588 62 12 NDD
2564 61 18 NDD 2589 62 13 NDD
2565 61 19 NDD 2590 62 14 NDD
2566 61 20 NDD 2591 62 15 NDD
2567 61 21 NDD 2592 62 16 NDD
2568 61 22 NDD 2593 62 17 NDD
2569 61 23 NDD 2594 62 18 NDD
2570 61 24 NDD 2595 62 19 NDD
2571 61 25 NDD 2596 62 20 NDD
2572 61 26 NDD 2597 62 21 NDD
2573 61 27 NDD 2598 62 22 NDD
2574 61 28 NDD 2599 62 23 NDD
2575 61 29 NDD 2600 62 24 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2601 62 25 NDD 2626 63 21 NDD
2601 62 26 NDD 2627 63 22 NDD
2601
2601 62 27 NDD 2628 63 23 NDD
2601
2601 62 28 NDD 2629 63 24 NDD
2601
2601
2601 62 29 NDD 2630 63 25 NDD
2601
2601
2601 63 1 NDD 2631 63 26 NDD
2601
2601
2601 63 2 NDD 2632 63 27 NDD
2601
2601
2601 63 3 NDD 2633 63 28 NDD
2601
2601
2601 63 4 NDD 2634 64 1 NDD
2601
2601
2601 63 5 NDD 2635 64 2 NDD
2601
2601
2601
2601
2601 63
2601 6 NDD 2636 64 3 NDD
2601
2601
2601 63
2601 7 NDD 2637 64 4 NDD
2601
2601 63 8 NDD 2638 64 5 NDD
2601
2601
2601
2601
2601 63 9 NDD 2639 64 6 NDD
2601
2601
2601
2601
2601 63 10 NDD 2640 64 7 NDD
2601
2601
2601
2601
2601 63 11 NDD 2641 64 8 NDD
2601
2601
2601
2601
2601
2601 63 12 NDD 2642 64 9 NDD
2601
2601
2601
2601
2601
2601 63 13 NDD 2643 64 10 NDD
2601
2601
2601
2601
2601
2601 63 14 NDD 2644 64 11 NDD
2601
2601
2601
2601
2601
2601 63 15 NDD 2645 64 12 NDD
2601
2601
2601
2601
2601
2601 63 16 NDD 2646 64 13 NDD
2601
2601
2601
2601
2601
2601 63 17 NDD 2647 64 14 NDD
2601
2601
2601
2601
2601
2601 63 18 NDD 2648 64 15 NDD
2601
2601
2601
2601
2601
2601 63 19 NDD 2649 64 16 NDD
2601
2601
2601
2601
2601
2601 63 20 NDD 2650 64 17 NDD
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
Astron2601
2601
Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground
2601 Head Office: Astron Group Office # 01 & 03, First Floor,
2601
2601
2601
2601
2601
FloorMugalivakkam
2601 Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
2601
2601
2601
2601
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
2601
2601
2601
2601
2601
2601
2601
2601
2601
2601
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2651 64 18 NDD 2676 65 14 NDD
2652 64 19 NDD 2677 65 15 NDD
2653 64 20 NDD 2678 65 16 NDD
2654 64 21 NDD 2679 65 17 NDD
2655 64 22 NDD 2680 65 18 NDD
2656 64 23 NDD 2681 65 19 NDD
2657 64 24 NDD 2682 65 20 NDD
2658 64 25 NDD 2683 65 21 NDD
2659 64 26 NDD 2684 65 22 NDD
2660 64 27 NDD 2685 65 23 NDD
2661 64 28 NDD 2686 65 24 NDD
2662 64 29 NDD 2687 65 25 NDD
2663 65 1 NDD 2688 65 26 NDD
2664 65 2 NDD 2689 65 27 NDD
2665 65 3 NDD 2690 65 28 NDD
2666 65 4 NDD 2691 66 1 NDD
2667 65 5 NDD 2692 66 2 NDD
2668 65 6 NDD 2693 66 3 NDD
2669 65 7 NDD 2694 66 4 NDD
2670 65 8 NDD 2695 66 5 NDD
2671 65 9 NDD 2696 66 6 NDD
2672 65 10 NDD 2697 66 7 NDD
2673 65 11 NDD 2698 66 8 NDD
2674 65 12 NDD 2699 66 9 NDD
2675 65 13 NDD 2700 66 10 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2701 67 1 NDD 2726 68 18 NDD
2702 67 2 NDD 2727 68 19 NDD
2703 67 3 NDD 2728 69 1 NDD
2704 67 4 NDD 2729 69 2 NDD
2705 67 5 NDD 2730 69 3 NDD
2706 67 6 NDD 2731 69 4 NDD
2707 67 7 NDD 2732 69 5 NDD
2708 67 8 NDD 2733 69 6 NDD
2709 68 1 NDD 2734 69 7 NDD
2710 68 2 NDD 2735 69 8 NDD
2711 68 3 NDD 2736 69 9 NDD
2712 68 4 NDD 2737 69 10 NDD
2713 68 5 NDD 2738 69 11 NDD
2714 68 6 NDD 2739 69 12 NDD
2715 68 7 NDD 2740 69 13 NDD
2716 68 8 NDD 2741 69 14 NDD
2717 68 9 NDD 2742 69 15 NDD
2718 68 10 NDD 2743 69 16 NDD
2719 68 11 NDD 2744 69 17 NDD
2720 68 12 NDD 2745 69 18 NDD
2721 68 13 NDD 2746 69 19 NDD
2722 68 14 NDD 2747 69 20 NDD
2723 68 15 NDD 2748 69 21 NDD
2724 68 16 NDD 2749 69 22 NDD
2725 68 17 NDD 2750 69 23 NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
FLAW FLAW
S. No. ROW Column WALL LOSS % S. No. ROW Column WALL LOSS %
TYPE TYPE
2751 70 1 NDD NDD
2752 70 2 NDD NDD
2753 70 3 NDD NDD
2754 70 4 NDD NDD
2755 70 5 NDD NDD
2756 70 6 NDD NDD
2757 70 7 NDD NDD
2758 70 8 NDD NDD
2759 70 9 NDD NDD
2760 70 10 NDD NDD
2761 11 NDD NDD
2762 12 NDD NDD
2763 13 NDD NDD
2764 NDD NDD
2765 NDD NDD
2766 NDD NDD
2767 NDD NDD
2768 NDD NDD
2769 NDD NDD
2770 NDD NDD
2771 NDD NDD
2772 NDD NDD
2773 NDD NDD
2774 NDD NDD
2775 NDD NDD
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
Recommendation: Tubes having >60% wall loss should be plugged.
SCOPE:
This procedure describes the method of applying Near Field Eddy Current
Testing (NFET) to test Ferromagnetic heat exchanger/boiler tubing.
This procedure is suitable for tube having tube OD 12.7 mm to 50.8 mm and
wall thickness to 0.71 mm to 3.4 mm
1.0REFERENCES
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
of Ferromagnetic Heat- Exchanger Tubes
Using Near Field Testing
2.0PERSONNEL QUALIFICATION
2.1 The personnel who operate the NFET test equipment with the exception
of the probe positioner / puller technician shall be a minimum Level-II in
Eddy current testing Method. Certification of the personnel shall be according
to ENSPL written practice.
2.2 The evaluation of the result of the NFET must be conducted by personnel
qualified to atleast Level II
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
NFT probes are specifically designed to detect internal corrosion, erosion, or
pitting on the ID of carbon steel tubing. These probes actually measure the lift-
off or “fill factor” and convert it to amplitude-based signals.
Calibration tube standards of similar material with artificial defects were used to
establish and verify the system response and to act as a guide for data analysis.
5.0SURFACE PREPARATION
All tubes inner surface shall be adequately cleaned to remove any dust, loose
foreign particles, internal deposits or contaminants by a suitable process such
as pressurized water jet cleaning. It is also recommended to clean the outer
surface of tube if possible.
6.0SITE REQUIREMENT
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
NFET system requires a 110/220 VAC, 50 Hz AC supply at work location.
7.2 The inspection is conducted with the probe located at the far end of the
tube. The assembly is pushed to the end of the tube by feeding the hose
through the end plate of the adaptor.
7.3 To start the inspection the assembly is gradually pulled along the tube
towards the operator. The rate at which the inspection head assembly is
moved along the tube governs the degree of coverage of the tube.
7.4 The above procedure can be repeated for as many tubes are to be
inspected during the operating session. The equipment dismantle
procedures are to be inspected during the operating session. The equipment
dismantle procedures are the reverse of those carried out during the set up
of the inspection.
7.5 The pulling speed of the probe shall be kept constant during the
inspection. The pulling speed shall be at 40-80mm/s
12.1 Report shall be prepared with the information gathered using the
computer data files
12.2 Report all tubes wall with a wall loss reading, Percentage of wall
loss and cooler front view diagram with wall loss and all reports issued to
the clients shall be signed by the person performing the inspection.
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com
INSPECTION PERSONNEL
Lead Technician: Mr. Ravi Teja - ECT Level II
INSPECTION PERSONNEL
M/s. Arudra Engineers Private Limited
Astron Certification (India) Private Limited.New No. 1/30 (Old No. 1/7C), Ground Head Office: Astron Group Office # 01 & 03, First Floor,
FloorMugalivakkam Main Road, MugalivakkamChennai - 600125, Tamilnadu, Building # 13, Plot # 16, Mussafah M-44, PO Box: 4582,
India.Tel.: +91 - 44 - 4851 8666astron-india@astrongroup.com Abu Dhabi, United Arab Emirates.www.astrongroup.com