Problom 2.10, Dotormine the Péiseon’s ratio and bulk modulus of a matorial, for which
Young's modulus is 1.2 « 107 Niu? and modulus of rigidity ig 4.8 x 104 N/munt,
Problem 21, A bar of cross-section & mm. x 8 mm is subjected to an axial pull of
7000 N. The lateral dimension of the bar is found to be changed to 7.9985 mm x 7.9985 mm. If
the modulus of rigidity of the material is 0.8 x 105 N/mum®, determine the Poisson's ratio and
modulus of elasti
Problem 2.12. Calealate the modulus of rigidity and bulk modulus of « eylindrical bar
of diameter 30 mm and of length 1.5 m if the longitudinal strain in a bar during a tensile stress
ig four tiries the lateral strain, Find the ehange in volume, when tho bar is subjected to a
hydrostatic presoure of 109 Nimm®, Take = 1 x 10? Nim.
Problem 2.7.A steel rod 5m Jong and 30mm in diameter is subjected to an axial tensile
load of 60 kN. Determine the change in length, diameter and volume ofthe rod. Take E =2 x 10°
Nimmn® and Poisson's ratio = 0.25.
Problem 2.5. A metallic bar 300 mm x 100 muri x 40 min is subjected to a force of 5 kN
(tensile), 6 BN (tensile) and 4 RN (tensile) along x,,y and = directions respectively. Determine the
change in the volume of the block. Take E = 2 x10" Nimm and Poisson's ratio = 0.25.
Problem 3.3. rectangular bar of cross-sectional area of 11000 mt is subjested to a
tensile load P os shown in Fig. 3.3. The permissible normal and shear stresses on the oblique
plane BC ore given as 7 Nimm? and 3.5 Ninr® respectively. Determine the safe value of P.
Problom 3.6. The stresses at a point ia a bar are 200 Nimm® (tensile) and 100 Nim?
(compressive). Determine the resultant stress in magnitude and direction ona plane inclined ct
60" to the oxis of the major etress. Alvo determine the maximum intenaity of sheer stress in the
material at the point, (AMIE, Winter 1984)
Problem 3.9. Ata point in a strained material, the prineipal stresses are 100 Nimm?
tensile and 40 Nimm compressive. Determine the resuitant stress in magnitude and direction
‘on a plane inclined at 60° to the azis of the major principal stress. What is the maximum
intensity of shear siress in the material at the point ? (AMIR, Winter 1982)
—
Problem 3.11. Ata point within a body subjected to tio
tion, th arses are 80°Nin® anal and Blum’ tons Baek of ee se
aczompanied by a shear stress of 60 Nimt, Determine the normal stress, shear stress ond
resultant otene om an oblique pla ichnad a: an angle of ab withthe axis of minor tone
~ Problem 3.16. The normal stress in two mutually perpendicular directions are 600 Nimm#
and 300 Ninn? both tensile, The complinsentary shear stresves in these directions are of intensity
450 Nimm, Find the normal and tangential stresses on the to planes which are equally inclined
to the planes carrying the normal stresses mentianed above.