Sei sulla pagina 1di 6

-0 :

MO Class Name ParameterNode

numHs
Hsdsch ScchCo RNC
des

HsdpaFlexibleScheduler=Activated

1-1  :

MO Class Name Parameter Node

maxNumH
NodeBLocalCell sPdschCo Baseband
des

maxNumH
DU Radio
RbsLocalCell sPdschCo
Node
des

MO Class Name ParameterNode


numHs
Hsdsch PdschC RNC
odes
HsdpaDynamicCodeAllocation=Activated

2-2:

86/1553-HSD 101 0
MO Class Name ParameterNode

configure
Baseban
NodeBSectorCarrier dMaxTxP
d
ower

DU radio

Mo=TpaDevice

maxTotalOutputPower = -1 { -1, 1..160 }
The maximum total output power of the TPA device. The radio unit does not
always support all power values within the value range. If set to a power
value higher than supported by the radio unit , the power is rounded down
to the highest supported power, and the power truncated alarm is raised.
However, when reading the attribute the configured value is always
presented. The currently available maximum output power for each carrier
within the corresponding sector can be read through the attribute
Carrier::maxDlPowerCapability.

86/1553-HSD 101 0
MO Class Name ParameterNode
primaryC
UtranCell pichPowe RNC
r
MO Class Name ParameterNode
maximum
Transmis
UtranCell RNC
sionPowe
r

MO Class Name ParameterNode

maxDlPo
Baseban
NodeBLocalCell werCapa
d
bility

maxDlPo
DU Radio
RbsLocalCell werCapa
Node
bility

dlAttenuation

BseBand : Mo=RfBranch
DU radio : Mo=AntFeederCable
Parameter Description

Number of codes of SF=128 used for the HS-SCCH.

Parameter Description
Maximum number of HS-PDSCH codes allowed per cell.

Alarm Licensed Capacity Exceeded is given if:

? administrativeState=UNLOCKED and
? maxNumHsPdschCodes higher than the upper limit and
? Emergency Unlock is not activated
Where upper limit is:
? License key value if Licensed capacity 'Number of HSDPA Codes per cell' is enabled (see
licenseState in MO CapacityState) or
? default value (maximum 5 HS-PDSCH codes) if license key is disabled.

During Emergency Unlock, maximum 15 HS-PDSCH codes are allowed in each cell.
The maximum number of HS-PDSCH codes allowed per cell.

Dependencies: If license key 'Number of HS-PDSCH Codes per Cell' is enabled (see
NodeBFunction::licenseStateNumHsPdschCodes) and Licensing Emergency Unlock is not activated,
maxNumHsPdschCodes cannot be set to a higher value than the license key allows. If the license key is
disabled, maximum 5 HS-PDSCH codes are allowed per cell. If Licensing Emergency Unlock is activated,
maximum 15 HS-PDSCH codes are allowed per cell.
Takes effect: Increase takes effect immediately. Decrease takes effect gracefully (if more codes than the
new limit are used, the new limit will not apply until the RNC has reconfigured the physical shared channel
so that less codes than the new limit are used).

Parameter Description

Number of codes of SF=16 used for the HS-PDSCH.


86/1553-HSD 101 02 Uen
Parameter Description
Maximum absolute output power of sector carrier.

Output power is evenly distributed over antenna connectors used for TX transmission by the
sector carrier, unless attribute txBranchAPower is set.

Feature Psi-Coverage requires same attribute value for all NodeBSectorCarriers in given
NodeBLocalCell. Total cell power must be equally distributed over all sector carriers.

86/1553-HSD 101 02 Uen


Parameter Description
Power to be used for transmitting the PCPICH.
Unit: 0,1 dBm
Parameter Description
Maximum transmission power. This is the maximum power for all downlink channels that are
allowed to be used simultaneously in a cell, added together.
Unit: 0,1 dBm

Parameter Description
Maximum downlink power capability for the cell.

For a Combined Cell configuration, this value is the maximum DL power capability among the
sector carriers. For a Psi-Coverage configuration, this value is the sum of the sector carriers'
maximum DL power capabilities. The value is reported to the RNC.
The maximum downlink power capability for the cell. For a cell using more than one carrier, this
value is the maximum DL power capability among the carriers. The attribute value is reported to
the RNC.

Unit: 0.1 dBm


Undefined value: -1
Specification: 3GPP TS 25.433, NBAP, UTRAN Iub interface NBAP signalling

Potrebbero piacerti anche