Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
23 106
93 diam. 0.5mm
4x4mm
diam. 0.8mm diam. 0.8mm 107
93 diam. 1.2mm
110 106
105 109
93 diam.
26 0.8mm
103
107
diam 103
. 1m 103 diam.
m 1mm 108 107
103 93
107
diam. 1.2mm
110
23 Cut two 34mm pieces of walnut to make the anchor davits 104. Round off the lower ends and the drill two 0.8mm-diameter holes to simulate
the anchor hoisting pulleys. Fit the davit hoops 105 and nail the davit struts 106. In one of the sides of the davits, drill three 0.8mm-diameter
holes to fit the small eyebolts 93, and a 1mm-diameter hole to fit the belaying pins 103. Insert the davit levers 107 through the two small eyebolts 93
and in the ship’s hull drill a 1mm-diameter hole on the side of the gap through which the davit is to be inserted. Insert the davit and its lever through
their corresponding holes, and with the nails 26 pin the anchor davits to the bow forecastle deck. Fit the small rings 108 in the belaying pins 103 of the
davits. Fit the large eyebolt 109, the eight belaying pins 103 and the bitts 110 to the bow.