Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Important note:
1, please carefully read this tutorial, read operation again in the future!!!
2, please follow this tutorial provides methods, prohibition of altering those steps !!!
Upgrade steps:
1, download the firmware package extract the three files in the future, namely the brush machine
tools, firmware and Flash tutorials, as shown in the following figure:
Tips: the firmware name is for demo purposes only, actual name is subject to you extracted.
3.2, click on the top of the "one-click Flash", as shown in the following figure, and then select the
firmware package. --> Follow the steps below to select the firmware:
4, Tablet PC Shutdown and start flashing the firmware:
4.1, tablet computers to shut down. If the Tablet cannot be determined is in a shutdown state, you can
long press the power button forced shutdown 10-20 seconds.
Special reminder: If you have a Tablet PC, shutdown menu with "next quick boot" option, and is turned
on, please turn this feature off before shutdown (remove the tick), otherwise inaccessible brush machine
models.
4.2, tablet computer entered the brush machine models. Operation steps is: put home page key (if you
of flat Shang no home page key, please found volume reduction key) press don't let go, plug Shang
USB line, then again continuous short by boot key 5-10 times, stay computer right Xia angle tips found
new of hardware, and pop-up installation drive program of window Shi, again release home page key (or
volume reduction key), following figure displayed right installation drive:
Tips:
1. the computer will automatically pop up a few times on the found new hardware window, based on the
above, please complete the driver automatically installed;
2. If a driver cannot be installed automatically according to the above, you can manually upgrade tool
path points to the driver folder in the installation directory. The default path is: C:\Program
Files\OndaSuite\Drivers\AW_Driver folder;
3. the same computer only when the first brush is the only firmware will be asked to install the drivers,
firmware directly after the second brush the following window pops up !
4.3, drive after loading will start flashing the firmware, in turn according to the following diagram shows
operation:
At this point, the upgrade has completed. Turn off upgrade tool, disconnect the USB cable, if the Tablet
PC does not boot automatically, press the power button to manually switch on to. After upgrading the
first boot time will be slightly longer, please be patient for a while.
Notes:
1. If the upgrade failed, please disconnect the USB cable, and then long press the power button for 20
seconds or so to get the tablet computer forced shutdown, starting from the 4th step of the tutorial and
start again;